Ferric chloride aiding nitrite pretreatment for the enhancement of the quantity and quality of short-chain fatty acids production in waste activated sludge

Abstract

The production of short-chain fatty acids (SCFAs) via anaerobic fermentation of waste activated sludge (WAS) is often limited with poor quality of SCFAs and long fermentation time. To overcome these issues, we provided an efficient strategy by using ferric chloride (FC) to aid nitrite pretreatment. Experimental results showed that the maximal SCFAs production of 211.3 ± 3.1 mg COD/g VS was achieved with 4 mmol/L of FC integrated with 250 mg/L of nitrite pretreatment on day 5, which was 4.1-fold higher than that of the blank control (52 ± 5 mg COD/g VS, day 7). Besides, the enrichment of acetic acid was observed in the combined system, which accounted for 54.6 ± 3.5% of total SCFAs, while the proportion was only 31.5 ± 4.9% in the blank control. Propionic acid, isobutyric acid, n-butyric acid, n-valeric acid and isovaleric acid accounted for 14.7 ± 1.5%, 6.9 ± 1.4%, 7.4 ± 1.5%, 13.1 ± 1.0%, and 3.3 ± 1.5% of total SCFAs in the combined system and 22.8 ± 4.0%, 11.9 ± 3.0%, 6.7 ± 3.1%, 17.6 ± 2.0%, and 9.5 ± 3.9% of total SCFAs in the blank control, respectively. It was found that soluble proteins and carbohydrates in the combined system were higher than those in the blank control, suggesting that FC and nitrite pretreatment was beneficial for WAS disintegration. The fluorescence spectrum results suggested that FC and nitrite pretreatment improved the biodegradability of released organics, which provided more biodegradable substances for the subsequent SCFAs production. This was because the addition of FC induced the formation of free nitrous acid from nitrite. Besides, FC-induced iron reduction also promoted the conversion of recalcitrant organics to biodegradable organic matter. Microbial community structure analysis demonstrated that the functional bacteria involved in acetogenesis process such as Enterococcus, Proteiniclasticum, and Petrimonas were highly enriched due to the pretreatment of FC and nitrite, indicating this method could improve the relative abundance of SCFAs producers. Overall, this study revealed that the pretreatment of FC and nitrite promoted the formation of free nitrous acid and increased the yield of SCFAs, which provided a novel method for wastewater treatment plants to ameliorate the sewage treatment craft and rationally use the existing substances in WAS to enhance resource recovery.