Continued Development and Testing of a Novel Steerable Chest Tube, Extendable Infusion Cannula, and Portable Suction-Infusion Pump for Use in Austere and Transport Environments to Prevent Retained Hemothorax.

Abstract

With blunt and penetrating trauma to the chest, warfighters frequently suffer from hemothorax. Optimal management requires the placement of a chest tube to evacuate the blood. Malposition of the tube may be a causative factor of inadequate drainage (retained hemothorax). As a potential solution, we developed a previously reported steerable chest tube allowing accurate placement into a desired location to enhance effectiveness. To provide assisted aspiration, we developed a portable, battery-operated suction device capable of simultaneous or sequential infusion. This report details the ongoing progress of this project. Updated steerable tube and pump prototypes were designed and produced. The tubes were tested for feasibility in two pigs and one cadaver by fluoroscopically comparing tip positions after insertion by a number of providers. Measured drainage volumes comparing standard vs. steerable tubes after pleural infusion of 1,000 mL of saline in two pigs were compared. Testing of the pump focused on the accuracy of suction and volume functions. The steerable tube prototype consists of sequentially bonded segments of differing flexibility and an ergonomic tensioning handle. The portable suction pump accurately provides up to 80 cmH2O of suction, an infusion capability of up to 10 mL/min, and a 950 mL removable reservoir canister. After minimal training, providers easily and repeatedly placed the tip of the steerable tube in the lateral diaphragmatic sulcus in animals and cadavers. Arc was limited to the distal segment. Compared to a standard tube, the steerable tube placed along the diaphragm improved pleural fluid drainage volumes by 17%, although this did not reach statistical significance in six trials. These new prototypes represent substantial improvements and were performed according to expectations. We believe that this steerable chest tube and portable suction-infusion pump can be effectively used for warfighters with chest injuries in austere environments.