Compared efficiency of trauma versus scheduled orthopaedic surgery operating rooms in a university hospital

Abstract

BackgroundThe objective of this study was to contribute to an OR efficiency optimisation effort by comparing a trauma OR versus a scheduled surgery OR in a lower limb orthopaedic surgery department. HypothesisThe main hypothesis is that efficiency is lower in the trauma OR than in the scheduled surgery OR. The secondary hypothesis is that efficiency of the trauma OR is lower during weekends. Material and methodsThis prospective study was conducted in 2016 in the orthopaedic surgery department of a university hospital. Patients were divided into three groups based on whether they underwent scheduled surgery (SchOS), trauma surgery on a weekday (TSwk), or trauma surgery on a weekend (TSwkend). Actual OR occupancy time, allocated OR block time (BT), OR occupancy rate, patient entrance-to-incision time, incision-to-closure time, closure-to-post-anaesthesia care unit (PACU) entrance time, and clean-up/set-up time (T4) were measured. ResultsWe included 691 patients in the SchOS group, 819 in the TSwk group, and 327 in the TSwkend group. OR efficiency was lower in the TSwk group compared to the SchOS group (occupancy rate, 86% vs. 88%; p=10−4). All occupancy time components were longer in the TSwk group. However, each component accounted for similar total occupancy time proportions in the two groups, except for clean-up/set-up time, which was longer in the TSwk group (p<0.05). On average, entrance-to-incision time accounted for 31%, incision-to-closure time for 34%, closure-to-PACU time for 18%, and clean-up/set-up time for 17% of total occupancy time. Efficiency was lower in the TSwkend group than in the TSwk group (occupancy rate, 75% vs. 86%; p=10−4). The TSwkend group had shorter entrance-to-incision and incision-to-closure times (p<0.05) and a nearly 10% longer clean-up/set-up time (p<0.05). ConclusionEfficiency of the trauma OR, although lower compared to the scheduled orthopaedic surgery OR, was nevertheless satisfactory as assessed based on standard indicators. Of the four total occupancy time components, the first three accounted for similar proportions of the total; differences occurred only for clean-up/set-up time. Efforts to improve OR efficiency should focus on arrival of the first patient and turnover time. Level of evidenceII, prospective cohort study.