Chemical compositions and crystallization characteristics of SOS‐rich fats

Abstract

AbstractSOS‐rich fats have been developed to improve heat stable properties and fat bloom‐resistant abilities of chocolates, which is highly connected with their crystallization behaviors. Shea butter stearin (SBS) and mango kernel fat (MKF) are the typical SOS‐rich fats. Both contained high levels of stearic acid (45.06%–59.67%) and oleic acid (31.85%–39.97%), while 77.00%–86.88% of the oleic acid were distributed at the sn‐2 positions of triacylglycerol molecules, contributing to forming 78.04% of SOS in SBS and 47.85% of SOS in MKF. Their SOS levels were significantly higher than that in cocoa butter (CB, 25.43%). However, MKF contained the highest levels of SOO (15.59%), which was about six to eight times as likely that in SBS and CB (1.76%–2.66%). Further crystallization tests revealed that SBS and MKF exhibited similar rod‐like growth from instantaneous nuclei at 4°C. The former was then changed to become more spherulitic growth at 20°C significantly. Specifically, large feather‐like crystals corresponding to β form were observed in SBS at the final stage of crystallization at 20 and 30°C, while MKF exhibited smaller crystals. The higher concentration of SOO in MKF was considered as the softening factor. It was further supposed that constant crystallization at 20°C may be difficult for some fats (e.g., SOS < 30%) to form adequate amounts of β crystals. The results will provide information on making cocoa butter blends and chocolate tempering.