Strong Anion Exchange Material Research Articles

A pocket-sized 3D-printed attenuated total reflection-infrared filtometer combined with functionalized silica films for nitrate sensing in water

Strong anion-exchange materials carry a positive charge that allows them to trap and concentrate anions while releasing other anions. Here, we introduced a quaternary ammonium anion exchange group into mesoporous silica films coated on attenuated total reflection (ATR) crystals to enrich nitrate from aqueous phase in the volume probed by the evanescent field. The ion-exchange and enrichment capabilities of the films were characterized using FTIR spectroscopy. Thereby fast analyte enrichment and full sensor recovery were observed. In addition, high enrichment factors of up to 1600 were achieved. After characterization, these coated ATR crystals were used in a dedicated ATR-IR filtometer comprising a Fabry-Pérot filter detector unit and a miniaturized thermal emitter with a overall dimensions of only 80 mm × 120 mm × 70 mm. The filter covered the spectral region between 1250–1800 cm−1 allowing for recording IR spectra of nitrate enriched into the mesoporous silica film. The sensor was calibrated using the Langmuir adsorption model as calibration function. From this a limit of detection of 1.2 mg L−1 was derived for the ATR-IR filtometer. This emphasizes the high potential of functionalized mesoporous silica films combined with low-cost filtometers for portable water sensors.

Silica-based strong anion exchange media for protein purification

The main objective of our research was to develop silica-based, polymer-functionalized ion exchange materials for single-use bioprocess applications, with the ultimate goal of achieving maximal binding capacity for target proteins. Herein we report the utilization of Grace® wide pore silica gel and bonding the silica with cationic polymers. The strong anion exchange materials have been prepared by a two-step process involving initial bonding with two trimethoxysilanes and subsequent aqueous solution radical polymerization with quaternary ammonium ion containing monomers and an azo initiator. Using the binding capacities for bovine serum albumin (BSA), a model protein for the evaluation of the new materials, we optimized the processes with regard to the median pore size of the silica gel, as well as polymer composition and ratios, which were determined by reagent ratios and reaction conditions. The products were also characterized by both chemical and physical methods. It has been found that higher binding capacities are associated with lower ligand density and higher molecular weight for the attached polymers, with over 20% higher in both static and dynamic binding capacity values with the same amount of attached polymers. The advantages of a large pore size distribution and optimal median pore size for the base silica are discussed. Optimal pore size range of 500–1500Å and distribution of Span 90 for over 1.0 give the highest BSA binding capacities. Silica-based strong anion exchange materials showed excellent flow characteristics when packed into a column and were superior to commercial agarose-based strong anion exchange material with respect to dynamic binding capacity, elution of proteins, and baseline separation of a mixture of three model proteins.

Application of a strong anion exchange material in electrostatic repulsion–hydrophilic interaction chromatography for selective enrichment of glycopeptides

Glycoproteins are involved in various cellular activities, including inter- and extracellular signaling. However, glycopeptide signals are significantly suppressed by coeluting non-glycosylated peptides in mass spectrometry-based analysis. For detailed elucidation of the biological functions of glycoproteins, selective enrichment of glycopeptides from non-glycosylated peptides is crucial. In the present study, a SAX material, XCharge SAX, was used in a column in the ERLIC mode with the aim of specifically enriching glycopeptides. Enrichment conditions were initially optimized, and selectivity, glycosylation heterogeneity coverage and detection sensitivity of XCharge SAX were subsequently assessed. In the selectivity assessment, glycopeptides were effectively isolated from a peptide mixture (human serum immunoglobulin G (IgG) and human serum albumin digests) and a tryptic digest of human serum using XCharge SAX. In the evaluation of glycosylation heterogeneity coverage, five glycosites and eleven glycopeptides from horseradish peroxidase were identified after enrichment with XCharge SAX. In detection sensitivity assessment, glycopeptides within four orders of magnitude were identified after enrichment with XCharge SAX. In addition, volatile solvents were used in the loading and eluting buffers so that desalting was not necessary for ERLIC fractions. Our results collectively support the utility of XCharge SAX as a suitable chromatographic material for global glycosylation site analysis.

Hydrophilic Strong Anion Exchange (hSAX) Chromatography for Highly Orthogonal Peptide Separation of Complex Proteomes

Due to its compatibility and orthogonality to reversed phase (RP) liquid chromatography (LC) separation, ion exchange chromatography, and mainly strong cation exchange (SCX), has often been the first choice in multidimensional LC experiments in proteomics. Here, we have tested the ability of three strong anion exchanger (SAX) columns differing in their hydrophobicity to fractionate RAW264.7 macrophage cell lysate. IonPac AS24, a strong anion exchange material with ultralow hydrophobicity, demonstrated to be superior to other materials by fractionation and separation of tryptic peptides from both a mixture of 6 proteins as well as mouse cell lysate. The chromatography displayed very high orthogonality and high robustness depending on the hydrophilicity of column chemistry, which we termed hydrophilic strong anion exchange (hSAX). Mass spectrometry analysis of 34 SAX fractions from RAW264.7 macrophage cell lysate digest resulted in an identification of 9469 unique proteins and 126318 distinct peptides in one week of instrument time. Moreover, when compared to an optimized high pH/low pH RP separation approach, the method presented here raised the identification of proteins and peptides by 10 and 28%, respectively. This novel hSAX approach provides robust, reproducible, and highly orthogonal separation of complex protein digest samples for deep coverage proteome analysis.

Polyelectrolyte functionalized multi-walled carbon nanotubes as strong anion-exchange material for the extraction of acidic degradation products of nerve agents

Extraction, enrichment and gas chromatography mass spectrometric analysis of degradation products of nerve agents from water is of significant importance for verification of Chemical Weapons Convention (CWC) and gathering forensic evidence of use of nerve agents. Multi-walled carbon nanotubes (MWCNTs) were non-covalently functionalized with poly(diallyldimethylammonium chloride) (PDDA) to afford the cationic functionalized nano-tubes, which were used as solid-phase anionic-exchanger sorbents to extract the acidic degradation products of nerve agents from water. Extraction efficiencies of MWCNTs-PDDA were compared with those of mixed mode anion-exchange (HLB) and silica based strong anion-exchange (Si-SAX) cartridges. Optimized extraction parameters included MWCNTs-PDDA 12 mg, washing solvent 5 mL water and eluting solvent 3 mL of 0.1M aqueous HCl followed by 3 mL methanol. At 1 ng mL(-1) spiking concentration of mono- and di-basic phosphonic acids, MWCNTs-PDDA exhibited higher extraction efficiencies in comparison to Si-SAX and HLB. The limits of detection were achieved down to 0.05 and 0.11 ng mL(-1) in selected ion and full scan monitoring mode respectively; and limits of quantification in selected ion monitoring mode were achieved down to 0.21 ng mL(-1).

Particle-into-liquid sampler on-line coupled with solid-phase extraction-liquid chromatography–mass spectrometry for the determination of organic acids in atmospheric aerosols

In the present study, sample collection and preparation were directly integrated with a chromatographic system by coupling a particle-into-liquid sampler for the first time on-line with solid-phase extraction-liquid chromatography–tandem mass spectrometry. Several organic acids, such as adipic, hydroxyglutaric, mandelic, vanillic, cis-pinonic, pinic, azelaic and sebacic, were used in the research. For sample pretreatment and concentration, strong anion exchange material was used in the extraction. Sampling, extraction and analysis conditions were optimized to obtain reliable information about aerosol chemical composition. To evaluate the performance of the on-line coupled system, half of each sample was analysed on-line and the other half was derivatized and analysed off-line by gas chromatography–mass spectrometry. Comparison of the two techniques with use of t-test showed the results to be in an excellent agreement. Limits of detection of studied acids in on-line system were between 0.1 and 0.9 ng. The on-line coupled system is fast and reliable and a promising tool for the real time analysis of organic acids in atmospheric aerosols.

Sequential Enrichment of Sulfated Glycans by Strong Anion-Exchange Chromatography Prior to Mass Spectrometric Measurements

Structural characterization of sulfated glycans through mass spectrometry (MS) has been often limited by their low abundance in biological materials and inefficient ionization in the positive-ion mode. Here, we describe a microscale method for sequentially enriching sulfated glycans according to their degree of sulfation. This method is based on modifying the binding ability of strong anion-exchange material through the use of different sodium acetate concentrations, thus enabling fairly selective binding and a subsequent elution of different glycans according to their degree of sulfation. Before this enrichment, the negative charge on the sialic acid, which is commonly associated with such glycans, was eliminated through permethylation that is used to enhance the positive-ion mode matrix-assisted laser desorption/ionization time-of-flight mass spectrometry (MALDI-MS) signal for all glycans. This enrichment approach minimizes competitive ionization between sulfated and neutral glycans, as well as that between sulfated species with a different degree of sulfation. The described method was initially optimized using sulfated oligosaccharide standards, while its potential has been verified for the sulfated N-glycans originated from the bovine thyroid-stimulating hormone (bTSH), a glycoprotein possessing mono- and disulfated N-glycans. This enhancement of the MALDI-MS signal facilitates analysis of some otherwise undetected components.

On-line coupled dynamic sonication-assisted extraction–liquid chromatography for the determination of phenolic acids in Lamiaceae herbs

A fast and efficient on-line coupled dynamic sonication-assisted extraction –liquid chromatography (DSAE–LC) method was developed for the determination of phenolic acids in basil, oregano, rosemary, sage, spearmint and thyme. The extraction and chromatography were coupled via a solid-phase trap filled with strong anion exchange material. The relative standard deviations (RSDs) for the retention times were less than 0.4% and those for the peak heights less than 3% except for gallic acid (RSD 1.2% for the retention times and 11% for the peak heights). Limits of detection were below ∼3 ng.

Determination of Free and Conjugated Indole-3-Acetic Acid, Tryptophan, and Tryptophan Metabolites in Grape Must and Wine

Tryptophan (Trp) and its metabolites, especially indole-3-acetic acid (IAA), are considered to be potential precursors of 2-aminoacetophenone (AAP), an aroma compound that causes an "untypical aging off-flavor" (UTA) in Vitis vinifera wines. In this study, RP-HPLC with fluorescence detection was used for the qualitative and quantitative analysis of Trp and Trp metabolites in grape musts and wines to which different viticultural measures had been applied (time of harvest, soil treatment, leaf plucking, vine prune). An alkaline hydrolysis was developed to release bound IAA and Trp. A sensitive and selective determination of different Trp metabolites was achieved after solid phase extraction using a strong anion exchange material. In the examined grape musts, more than 95% of the total IAA was bound either as ester conjugate or as amide conjugate. Free IAA and other Trp metabolites were below the detection limit (<3 microg/L) or could be determined only in traces. Their amounts increased significantly during fermentation, whereas the amount of Trp decreased. It could be shown that the different viticultural measures applied (except the vine prune) as well as the climatic conditions of the vintage exhibited significant influences on the amounts of Trp and Trp metabolites in grape musts or wines.

Application of hydrophobic anion-exchange phases in capillary electrochromatography

Capillary electrochromatography (CEC) requires stationary phases that enable appropriate electroosmotic propel under various conditions. Analyte retention can be controlled through hydrophobic or electrostatic interaction with the packing material. The development and characterization of new strong anion-exchange materials with additional hydrophobic moieties (SAX/C 18 mixed-mode phases) is described. The synthesis was based on polymer encapsulation of porous silica. The phases were systematically characterized by means of elemental analyses, HPLC frontal analyses and CEC experiments. The studies focused on the influence of various parameters (e.g., pH, kind of buffer, capillary wall) on the electroosmotic flow (EOF). Phases with high anion-exchange capacity generated a fast and constant EOF over a wide pH range. Long-time stability of EOF and hydrophobic retention under CEC conditions were demonstrated within the course of 100 consecutive injections. The applicability of the SAX/C 18 phases in appropriate buffer systems is demonstrated for neutral, acidic and basic compounds.

Quaternized trimethylaminated polystyrene-coated zirconia as a strong anion exchange material for HPLC.

The synthesis and characterization of a new, base-stable, strong anion exchange phase by amination of polystyrene-coated zirconia (PS-ZrO2) are described. Even though the ion exchange capacity of the quaternized trimethylaminated PSZrO2 (QTMA-PS-ZrO2) is only 0.07 mequiv/g, it is able to separate various inorganic anions, benzoic acid derivatives, and nucleotides in their deprotonated states. The effects of ionic strength, eluent pH, and counterion type are discussed. In the presence of both phosphate and fluoride ions in the eluent, band broadening caused by Lewis acid/base interactions between zirconia and analytes is greatly suppressed. The mixed retention modes (ion exchange, hydrophobic interaction, and Lewis acid/base interactions) on QTMA-PS-ZrO2 offer a different selectivity toward various anionic analytes than do other zirconia- and nonzirconia-based ion exchangers.

The Efficient Removal of Endotoxins from Insulin Using Quaternized Polyethyleneimine-Coated Porous Zirconia

The synthesis and use of a zirconia-based, alkali-stable strong anion-exchange stationary phase are described for the removal of pyrogenic lipopolysaccharides (LPS) from insulin. The strong anion-exchange material is produced by deposition of polyethyleneimine (PEI) onto porous zirconia particles, followed by cross-linking with a novel reagent, 1,2-bis-(2-iodoethoxy) ethane, and quaternization with iodomethane. Physical characterization of the chromatographic support shows that it has an ion-exchange capacity of 0.6 mmol/g, and 82% of the amine sites on the surface are in quaternized form. Isocratic elution of small benzoic acid derivatives shows good column efficiency. The two primary virtues of this material are its chemical stability under alkali conditions (up to pH 13) and its lower hydrophobicity compared to previously described alkali-stable PEI-coated zirconia supports cross-linked with 1,10-diiododecane. Using this new zirconia-based phase, a purification protocol is developed for the efficient removal of Escherichia coli 0111:B4 LPS from bovine insulin samples. An endotoxin clearance rate of up to 1.3 × 108 was attained. Endotoxin levels were reduced to less than 5 endotoxin units/ml even at initial contamination levels as high as 5.0 × 106 endotoxin units/ml. Furthermore, endotoxin adsorbed to the porous zirconia column may be easily removed (depyrogenated) using alkali for repeated purification cycles.

Quantitative peptide bioanalysis using column-switching nano liquid chromatography/mass spectrometry.

Many endogenous peptides are circulating in bodily fluids at the low pmol l-1 range, placing high demands on the bioanalytical procedure. In order to analyze these minute concentrations in complex matrices, a miniaturized liquid chromatography/electrospray ionization mass spectrometry (LC/ESI-MS) bioanalysis method was developed using custom-made nanoLC columns (75 microns i.d.) and a micro-electrospray interface (micro ESI). To be able to analyze large sample volumes in order to cope with low biological analyte concentrations, the nanoLC/ESI-MS method was coupled to an on-line preconcentration (PC) system based on a strong anion-exchange material. This method was used to analyze endothelin peptides (ETs) in complex matrices, which are potent vasoconstrictors of M(r) approximately 2500 Da. The ET isoforms could be simultaneously analyzed with detection limits down to 30 pmol l-1 in cell supernatants (1.5 fmol on column). The method was linear from 50 to 2000 pmol l-1 with correlation coefficients of 0.99 for two of the three endothelin isoforms. Several other parameters, such as matrix effects and recovery, were also investigated.

Quantitative peptide bioanalysis using column‐switching nano liquid chromatography/mass spectrometry

Many endogenous peptides are circulating in bodily fluids at the low pmol l-1 range, placing high demands on the bioanalytical procedure. In order to analyze these minute concentrations in complex matrices, a miniaturized liquid chromatography/electrospray ionization mass spectrometry (LC/ESI-MS) bioanalysis method was developed using custom-made nanoLC columns (75 μm i.d.) and a micro-electrospray interface (μESI). To be able to analyze large sample volumes in order to cope with low biological analyte concentrations, the nanoLC/ESI-MS method was coupled to an on-line preconcentration (PC) system based on a strong anion-exchange material. This method was used to analyze endothelin peptides (ETs) in complex matrices, which are potent vasoconstrictors of Mr≈2500 Da. The ET isoforms could be simultaneously analyzed with detection limits down to 30 pmol l-1 in cell supernatants (1.5 fmol on column). The method was linear from 50 to 2000 pmol l-1 with correlation coefficients of 0.99 for two of the three endothelin isoforms. Several other parameters, such as matrix effects and recovery, were also investigated. © 1998 John Wiley & Sons, Ltd.