Recirculating Nutrient Film Technique Research Articles

Dynamics of micro and macronutrients in a hydroponic nutrient film technique system under lettuce cultivation

While hydroponics is considered an efficient vegetable production system, there is a compelling need to investigate the efficiency of the current generic nutrient dosing recommendation primarily based on electrical conductivity (EC) measurements. Such information is critical to fine-tune and optimize the current hydroponic management practices for improved nutrient uptake efficiency. This study investigated the dynamics of some micro and macronutrients (N, P, Ca, Mg, K, Fe, and Mn) in a recirculating nutrient film technique (NFT) hydroponic system under lettuce cultivation. The research was conducted in an indoor controlled environment growth chamber with lettuce grown in different EC levels (1.2 and 1.6 dS m−1). Each treatment had four hydroponic cultivation units, each one with 24 plants. Nutrient solution and tissue samples were collected two to three times per week. Nutrient dynamics, including nutrient uptake efficiencies and environmental losses, were calculated using a mass balance approach. The effects of EC level on fresh and dry lettuce biomass and nutrient uptake were insignificant. Observed variations in nutrient solution composition during lettuce cultivation included the almost complete removal of ammonia nitrogen, nitrate decreases towards the end of the experiment, consistent increases in aqueous Ca concentration, and corresponding decreases in K and Mn. Average N losses ranged between 27 and 40 %, presumably through denitrification, while 10–14 % of N was assimilated into the plant biomass. The remaining N in the recirculating nutrient solution was estimated to be between 50 and 59 %. The average P loss was 11–35 %, likely due to precipitation, while 52–77 % remained in the nutrient solution. Nutrient uptake efficiencies averaged 19–31 % K, 12–21 % P, 9–16 % Mn, 4–6 % Ca, 3–4 % Mg, and 2–4 % Fe. These results suggest that elevated nutrient concentrations in recirculating nutrient solutions led to losses and underutilization. Findings from this study provide a comprehensive dataset critical to improving hydroponic nutrient management beyond N and P. Hydroponic nutrient management should target providing essential nutrients needed by plants at the correct proportions considering the plant growth stage.

Effect of reduced atmospheric pressure on growth and quality of two lettuce cultivars

Future space missions will likely include plants to provide fresh foods and bioregenerative life support capabilities. Current spacecraft such as the International Space Station (ISS) operate at 1 atm (101 kPa) pressure, but future missions will likely use reduced pressures to minimize gas leakage and facilitate rapid egress (space walks). Plants for these missions must be able to tolerate and grow reliably at these reduced pressures. We grew two lettuce cultivars, ‘Flandria’ a green bibb-type and ‘Outredgeous,’ a red, loose-leaf type, under three pressures: 96 kPa (ambient control), 67 kPa (2/3 atm), and 33 kPa (1/3 atm) for 21 days in rockwool using recirculating nutrient film technique hydroponics. Each treatment was repeated three times using a different hypobaric chamber each time. A daily light integral of 17.2 Moles Photosynthetically Active Radiation per day was provided with metal halide lamps set to deliver 300 µmol m−2s −1 photosynthetic photon flux (PPF) for a 16 h photoperiod at 22 °C. Oxygen was maintained at 21 kPa (equal to 21% at 1 atm) and CO2 at 0.12 kPa (equal to 1200 ppm at 1 atm). Leaf area for ‘Outredgeous’ was reduced 20% and 38% at 67 kPa and 33 kPa respectively; shoot fresh mass was reduced 22% and 41% at 67 kPa and 33 kPa respectively when compared to control plants at 96 kPa. These trends were not statistically significant at P ≥ 0.05. Leaf area for ‘Flandria’ showed no difference between 96 and 67 kPa but was reduced 31% at 33 kPa; shoot fresh mass was reduced 6% and 27% at 66 kPa and 33 kPa respectively compared to 96 kPa. There were 10% and 25% increases in anthocyanin concentration at 66 kPa and 33 kPa compared to 96 kPa, potentially increasing the bioprotective capacity of the plant. Previous studies with other cultivars of lettuce showed slight change in growth across this range of pressures, suggesting responses may vary among genotypes, hypobaric exposure treatments, and / or environmental conditions. Collectively, the findings suggest further testing is needed to understand the effects of atmospheric pressure on plant growth.

Quality and Yield of Lettuce in an Open-Air Rooftop Hydroponic System

In this study, the yield and growth performance of lettuce in an open-air rooftop hydroponic system were investigated. Lettuce was grown in a closed recirculating nutrient film technique (NFT) unit using a standard nutrient solution (NS). Yield, fresh weight, and nutrient content in the leaf tissue of the harvested lettuce were measured. The results were compared with the results obtained in indoor hydroponic lettuce growth with artificial lightning. Despite strong winds during the growth period, 25% of the total lettuce heads weighed twice the marketable weight; however, 25% of the total lettuce heads were below the marketable weight. A more efficient nutrient uptake was indicated by the lettuces in the rooftop system compared with the uptake in the indoor system. Foliar analysis revealed a higher content of all nutrients in the leaves of rooftop hydroponic lettuce compared with indoor hydroponic lettuce. This study suggests that hydroponic rooftop-grown lettuce can be competitive with their indoor counterparts if the rooftop hydroponic system is protected from extreme weather conditions.

Effect of Plant Density on the Yield of Hydroponically Grown Heat-Tolerant Tomato under Summer Temperature Conditions

Producing enough tomato to meet market demand sustainably has not been feasible in the tropics like Ghana. Attempts to improve production using greenhouse facilities have not addressed the challenge because of high-temperature conditions in the greenhouse, which are difficult to manage. Heat stress, arising from high temperatures, hinder the performance of tomato in terms of fruit set and yield. Moreover, the impending climate change is expected to impose more unfavorable environmental conditions on crop production. An experiment was conducted in (greenhouse at Chiba University, Japan) summer period, which has similar high-temperature conditions like Ghana. This work sought to increase the yield of a heat-tolerant tomato using a state-of-the-art hydroponic system through high-density planting. The outcome of this work was intended for adoption and practice in Ghana. A Heat-tolerant tomato “Nkansah HT” along with Lebombo and Jaguar cultivars, were grown at high and low plant densities (4.1 and 2.7 plants m-2 respectively). Each plant was grown in a low substrate volume culture (0.5 L plant-1) in a recirculating nutrient film technique (NFT) hydroponic system. Parameters measured were plant growth and dry matter assimilation at 12 weeks after transplanting, and the generative components. Results showed that a high plant density increased plant height but reduced chlorophyll content by 9.6%. Under temperature stress conditions, the three cultivars recorded more than 95% fruit set, but plant density did not affect the fruit set and the incidence of blossom end rot (BER). The incidence of BER reduced the marketable yield of the Jaguar cultivar by 51% but, this physiological disorder was not recorded in the HT and the Lebombo cultivars. A high-density planting increased the yield per unit area increased by 38.9%. However, it is uneconomical to cultivate the Jaguar cultivar under a heat stress condition due to its high susceptibility to blossom end rot. To improve the yield of tomatoes under tropical heat stress with a threatening climate change condition, the HT is a better cultivar suited for high-density planting. This study shows that high-density cultivation of the HT cultivar in NFT hydroponic system has the potential to increase Ghana’s current tomato yield by 4.8 times.

Development and testing of re-circulating nutrient film technique

Development and testing of re-circulating nutrient film technique

Oxygen consumption in recirculating nutrient film technique in aquaponics

Due to root respiration, a minimum oxygen concentration in the root zone of plants is necessary. To keep the plant healthy and fully efficient the concentration should not fall below a plant specific critical value. Especially in nutrient film technique, the oxygen concentration can deplete heavily during the daytime. Besides the root respiration also microorganisms, living in the root zone of the plants, consume oxygen and have to be considered. In double recirculating aquaponic systems (DRAPS) fish waste water is used for preparation of nutrient solution for plant production in hydroponics. The fish waste water, delivered by a recirculating aquaculture system (RAS), probably contains high amounts of microorganism which can compete with plants for oxygen.The present study was conducted to investigate the oxygen concentration of nutrient solutions used in both, conventional hydroponics and in DRAPS, respectively. Therefore, the oxygen concentration within the cultivation trenches of conventional hydroponics (control; nutrient solution prepared with fresh water, electrical conductivity (EC) 1.8 dS m−1) and DRAPS (nutrient solution prepared with fish waste water (AP), EC 1.8 dS m−1 (low) and EC 3.0 dS m−1 (high)) were investigated. To evaluate whether the differences in oxygen depletion might be almost due to the used process water, the oxygen consumption of the prepared nutrient solutions was investigated separately without plants.The oxygen concentration within the cultivation trenches followed a typical daily fluctuation pattern with a decreasing oxygen concentration during the day. As time passed from April to June the depletion during the day increased and was strongest in AP high. In June the oxygen concentration dropped partly to zero in AP high, while it dropped only to nearly 150 μmol L−1 and 60 μmol L−1 in control and AP low, respectively. The oxygen consumption of pure nutrient solution (without plants) was significantly different between AP high and control, which also affects the oxygen concentration within the cultivation trenches.

Process and Product: Recirculating Hydroponics and Bioactive Compounds in a Controlled Environment

NASA has investigated the use of recirculating nutrient film technique (NFT) systems to grow higher plants on long-duration space missions for many years and has demonstrated the feasibility of using recirculating systems on numerous crop species. A long duration (418-day) experiment was conducted at Kennedy Space Center, Fla., to evaluate the feasibility of using recirculating hydroponics for the continuous production of Solanum tuberosum L. `Norland'. The productivity of four sequential batch plantings was compared to staggered harvest and plantings. The accumulation of bioactive organic compounds in the nutrient solution resulted in reduced plant height, induced early tuber formation, and increased harvest index of the crops in both production systems. The changes in crop development were managed by increasing planting density and reducing cycle time to sustain production efficiency.

Influence of Nitrogen Nutrition Management on Biomass Partitioning and Nitrogen Use Efficiency Indices in Hydroponically Grown Potato

The National Aeronautics and Space Administration (NASA) has been conducting controlled environment research with potatoes (Solanum tuberosum L.) in recirculating nutrient film technique (NFT)-hydroponic systems as a human life support component during long-duration spaceflight. Standard nutrient solution management approaches include constant pH regulation with nitric acid (HNO3) and daily adjustment of electrical conductivity (EC) equivalent to half-strength modified Hoagland's solution, where nitrate (NO3-) is the sole nitrogen (N) source. Although tuber yields have been excellent with such an approach, N use efficiency indices are expected to be low relative to tuber biomass production. Furthermore, the high amount of N used in NFT-hydroponics, typically results in high inedible biomass, which conflicts with the need to minimize system mass, volume, and expenditure of resources for long-duration missions. More effective strategies of N fertilization need to be developed to more closely match N supply with demand of the crop. Hence, the primary objective of this study was to identify the optimal N management regime and plant N requirement to achieve high yields and to avoid inefficient use of N and excess inedible biomass production. In separate 84-day cropping experiments, three N management protocols were tested. Treatments which decreased NO3(-)-N supply indirectly through lowering nutrient solution EC (Expt. I), or disabling pH control, and/or supplying NH4(+)-N (Expt. III) did not significantly benefit tuber yield, but did influence N use efficiency indices. When supplied with an external 7.5 mM NO3(-)-N for the first 42 days after planting (DAP), lowered to 1.0 mM NO3(-)-N during the final 42 days (Expt. II), plants were able to achieve yields on par with plants which received constant 7.5 mM NO3(-)-N (control). By abruptly decreasing N supply at tuber initiation in Expt. II, less N was taken up and accumulated by plants compared to those which received high constant N (control). However, proportionately more plant accumulated N was used (N use efficiency) to produce tuber biomass when N supply was abruptly lowered at tuber initiation in Expt. II. Hence, a hydroponic nutrient solution N management system may be modified to elicit greater plant N-use while maintaining overall high tuber yield as opposed to achieving high tuber yields through excess N supply and shoot growth.

Glycine betaine accumulation, ionic and water relations of red-beet at contrasting levels of sodium supply

Exposure of plants to sodium (Na) and salinity may increase glycine betaine accumulation in tissues. To study this, red-beet cvs. Scarlet Supreme and Ruby Queen, were grown for 42 days in a growth chamber using a re-circulating nutrient film technique with 0.25 mmol/L K and either 4.75 mmol/L (control) or 54.75 mmol/L (saline) Na (as NaCl). Plants were harvested at weekly intervals and measurements were taken on leaf water relations, leaf photosynthetic rates, chlorophyll fluorescence, chlorophyll levels, glycine betaine levels, and tissue elemental composition. Glycine betaine accumulation increased under salinity and this accumulation correlated with higher tissue levels of Na in both cultivars. Na accounted for 80 to 90% of the total cation uptake under the saline treatment. At final harvest (42 days), K concentrations in laminae ranged from approximately 65-95 micromoles g-1 dry matter (DM), whereas Na in shoot tissue ranged from approximately 3000-4000 micromoles g-1. Leaf sap osmotic potential at full turgor [psi(s100)] increased as lamina Na content increased. Glycine betaine levels of leaf laminae showed a linear relationship with leaf sap [psi(s100)]. Chlorophyll levels, leaf photosynthetic rates, and chlorophyll fluorescence were not affected by Na levels. These results suggest that the metabolic tolerance to high levels of tissue Na in red-beet could be due to its ability to synthesize and regulate glycine betaine production, and to control partitioning of Na and glycine betaine between the vacuole and the cytoplasm.

Relative humidity around the fruit influences the mineral composition and incidence of blossom-end rot in weet pepper fruit

SummarySweet pepper plants of cultivar Domino were grown using the hydroponic recirculating nutrient film technique (NFT) at an EC of 2 dS m -1 during the autumn season. Two experiments examined the effects of relative humidity (r.h.) around the fruit on the accumulation of Ca, Mg and K on fruit of known age from date of anthesis. The humidity treatments used in the first experiment were on average 30%, 50% and 80% and an ambient humidity achieved by covering sweet pepper fruit with polyethylene bags containing 50 g each CaCl2, NaCl or polyethylene bags without salts. The second experiment used an airflow system to generate average r.h. levels of 20%, 40% and 80%. In both experiments high r.h. levels reduced the accumulation of Ca by the fruit. The r.h. treatments particularly reduced the Ca concentration in the distal end of the fruit, which resulted in a higher incidence of blossom-end rot in experiment I, and with no statistically signficant effect in experiment II. The incidence appears to be related to the Ca concentration as well as the ratio of this element to Mg and K at the distal end. On the other hand, low r.h. promoted the accumulation of Ca in fruit particularly towards fruit maturity. R.h. had little effect on accumulation of Mg and K in sweet pepper fruit and affected fruit mass only at maturity.

Proximate Composition, Amino Acid Profile, Fatty Acid Composition, and Mineral Content of Peanut Seeds Hydroponically Grown at Elevated CO2 Levels

Peanut plants (Arachis hypogaea L. cv. Georgia Red) were grown hydroponically using a recirculating nutrient film technique. The effect of CO2 enrichment on nutritive composition of hydroponic peanut seeds was examined at two elevated CO2 levels (700 and 1400 ppm) that simulate potential conditions in National Aeronautics and Space Administration (NASA) Controlled Ecological Life-Support Systems (CELSS) and compared to ambient CO2 condition in hydroponics (the control). Plants were harvested at 97 days after planting, and the seeds were air-dried and analyzed for composition. Percentages of crude protein, crude fat, ash, and carbohydrate of hydroponic peanut seeds were around 30%, 30%, 3%, and 30%, respectively. The major amino acids were aspartic acid, glutamic acid, and arginine. The limiting amino acid of peanut, methionine, was 1.2%. Linoleic acid was the major fatty acid, followed by oleic and palmitic acids. The major mineral elements were K, P, Mg, and Ca. The results showed that certain peanut var...

Foliage Removal Influences Sweetpotato Biomass Yields in Hydroponic Culture

Greenhouse studies were conducted to determine the effect of harvesting sweetpotato [Ipomoea batatas L. (Lam.)] foliage tips (terminal 15 cm) on storage root yield, edible biomass index (EBI), and linear growth rate. Plants were grown hydroponically from 15-cm vine cuttings planted in 0.15 × 0.15 × 1.2-m growth channels using a recirculating nutrient film technique system. Nutrients were supplied from a modified half-strength Hoagland solution with a 1 N: 2.4 K ratio. Foliage tips were removed at 14-day intervals beginning 42 days after transplanting. Final harvest was at 120 days after planting. At the end of the growing season, harvested foliage tips totaled 225 g/plant (fresh mass). Foliage removal significantly reduced storage root yield, shoot biomass, and linear growth rate expressed on a canopy cover basis. The EBI was higher for plants with foliage removed than for the control.

Peanut Production using Recirculating Nutrient Film Technique (NFT)

As part of NASA's effort with bioregenerative life support systems, the growth of candidate crops is being investigated in controlled environments. Peanut (Arachis hypogaea L.) was selected for the high oil and protein content of its seed. Peanut cvs. Pronto and Early Bunch were grown from seed, using recirculating nutrient film technique (NFT) in 6-cm-deep, trapazoidal culture trays. The trays were fitted with slotted covers, which allowed developing pegs to reach the root zone. Use of a separate moss-filled pegging compartment above the root zone (tray within a tray) had little effect on seed yield, but resulted in a 60% increase in the nitric acid requirements for pH control. Yields from both cultivars were equivalent to field values on an area basis; however, harvest indices were lower than field values due to the luxuriant canopy growth under controlled environment conditions. Proximate analysis of seeds was similar to field values, with the exception of fat, which was ≈15% lower, and ash, which was ≈30% greater under controlled environment conditions, regardless of cultivar.

Accumulation of Possible Potato Tuber-inducing Factor in Continuous-use Recirculating NFT sSystem

Potatoes (Solanum tuberosum L.) have been grown successfully with a recirculating nutrient film technique (NFT) when a fresh nutrient solution is used for each planting. During the past year, we conducted two studies in which the same nutrient solution was used for successive plantings (EC and pH were maintained at 0.12 S·m–1 and 5.8). Results showed that successive plantings became prematurely induced (tubers initiating near 20 days after planting–DAP), causing stunted shoot growth and reduced yields per plant. When “old” nutrient solution from a continuous production system was regularly added to a newly started plant system maintained under a non-inductive environment (12-h photoperiod with night break of 6 h into dark), tubers formed on “old” nutrient solution plants (24 DAP), but not on “new” solution plants. When charcoal water filters were placed on the systems, plants grown on either “old” or “new” nutrient solutions showed no tuber initiation (plants harvested at 42 DAP). Results suggest that a tuber-inducing factor(s) emanating from the plants accumulates in the nutrient solution over time and that the factor(s) can be removed by charcoal absorption.

Peanut Production using Recirculating Nutrient Film Technique (NFT)

As part of NASA's effort with bioregenerative life support systems, the growth of candidate crops is being investigated in controlled environments. Peanut (Arachis hypogaea L.) was selected for the high oil and protein content of its seed. Peanut cvs. Pronto and Early Bunch were grown from seed, using recirculating nutrient film technique (NFT) in 6-cm-deep, trapazoidal culture trays. The trays were fitted with slotted covers, which allowed developing pegs to reach the root zone. Use of a separate moss-filled pegging compartment above the root zone (tray within a tray) had little effect on seed yield, but resulted in a 60% increase in the nitric acid requirements for pH control. Yields from both cultivars were equivalent to field values on an area basis; however, harvest indices were lower than field values due to the luxuriant canopy growth under controlled environment conditions. Proximate analysis of seeds was similar to field values, with the exception of fat, which was ≈15% lower, and ash, which was ≈30% greater under controlled environment conditions, regardless of cultivar.

Supraoptimal Carbon Dioxide Effects on Growth of Soybean [ Glycine max (L.) Merr.

In tightly closed environments used for human life support in space, carbon dioxide (CO2) partial pressures can reach 500 to 1000 Pa, which may be supraoptimal or toxic to plants used for life support. To study this, soybeans [Glycine max (L.) Merr. cvs. McCall and Pixie] were grown for 90 days at 50, 100, 200, and 500 Pa partial pressure CO2 (500, 1000, 2000, and 5000 ppm). Plants were grown using recirculating nutrient film technique with a 12-h photoperiod, a 26 degrees C/20 degrees C thermoperiod, and approximately 300 micromoles m-2 s-1 photosynthetic photon flux (PPF). Seed yield and total biomass were greatest at 100 Pa for cv. McCall, suggesting that higher CO2 levels were supraoptimal. Seed yield and total biomass for cv. Pixie showed little difference between CO2 treatments. Average stomatal conductance of upper canopy leaves at 50 Pa CO2 approximately 500 Pa > 200 Pa > 100 Pa. Total water use over 90 d for both cultivars (combined on one recirculating system) equalled 822 kg water for 100 Pa CO2, 845 kg for 50 Pa, 879 kg for 200 Pa, and 1194 kg for 500 Pa. Water use efficiences for both cultivars combined equalled 3.03 (g biomass kg-1 water) for 100 Pa CO2, 2.54 g kg-1 for 200 Pa, 2.42 g kg-1 for 50 Pa, and 1.91 g kg-1 for 500 Pa. The increased stomatal conductance and stand water use at the highest CO2 level (500 Pa) were unexpected and pose interesting considerations for managing plants in a tightly closed system where CO2 concentrations may reach high levels.