Mg Of Free Chlorine Research Articles

Assessment of the efficacy of benzalkonium chloride and sodium hypochlorite against Acanthamoeba polyphaga and Tetrahymena spp.

The efficacy of benzalkonium chloride and sodium hypochlorite against Acanthamoeba polyphaga and two Tetrahymena spp. was determined based on the European Standard EN 1276:2009 suspension test. Trophozoite viability was assessed by determination of the membrane integrity using flow cytometry as a fast screening technique. Bovine serum albumin was added to simulate clean (0.3 g/liter) and dirty (3 g/liter) conditions. Benzalkonium chloride caused cell lysis at concentrations above 50 mg/liter under clean and dirty conditions. A concentration of 50 mg of free chlorine per liter had a strong biocidal effect on acanthamoebae and tetrahymenae after 15 min under clean and dirty conditions. Our results suggest that benzalkonium chloride and sodium hypochlorite were effective against the three microorganisms at concentrations commonly applied in the food industry.

Inactivation of Adenoviruses, Enteroviruses, and Murine Norovirus in Water by Free Chlorine and Monochloramine

Inactivation of infectious viruses during drinking water treatment is usually achieved with free chlorine. Many drinking water utilities in the United States now use monochloramine as a secondary disinfectant to minimize disinfectant by-product formation and biofilm growth. The inactivation of human adenoviruses 2, 40, and 41 (HAdV2, HAdV40, and HAdV41), coxsackieviruses B3 and B5 (CVB3 and CVB5), echoviruses 1 and 11 (E1 and E11), and murine norovirus (MNV) are compared in this study. Experiments were performed with 0.2 mg of free chlorine or 1 mg of monochloramine/liter at pH 7 and 8 in buffered reagent-grade water at 5 degrees C. CT values (disinfectant concentration x time) for 2- to 4-log(10) (99 to 99.99%) reductions in virus titers were calculated by using the efficiency factor Hom model. The enteroviruses required the longest times for chlorine inactivation and MNV the least time. CVB5 required the longest exposure time, with CT values of 7.4 and 10 mg x min/liter (pH 7 and 8) for 4-log(10) inactivation. Monochloramine disinfection was most effective for E1 (CT values ranged from 8 to 18 mg x min/liter for 2- and 3-log(10) reductions, respectively). E11 and HAdV2 were the least susceptible to monochloramine disinfection (CT values of 1,300 and 1,600 mg-min/liter for 3-log(10) reductions, respectively). Monochloramine inactivation was most successful for the adenoviruses, CVB5, and E1 at pH 7. A greater variation in inactivation rates between viruses was observed during monochloramine disinfection than during chlorine disinfection. These data will be useful in drinking water risk assessment studies and disinfection system planning.

Rotavirus virus-like particles as surrogates in environmental persistence and inactivation studies.

Virus-like particles (VLPs) with the full-length VP2 and VP6 rotavirus capsid proteins, produced in the baculovirus expression system, have been evaluated as surrogates of human rotavirus in different environmental scenarios. Green fluorescent protein-labeled VLPs (GFP-VLPs) and particles enclosing a heterologous RNA (pseudoviruses), whose stability may be monitored by flow cytometry and antigen capture reverse transcription-PCR, respectively, were used. After 1 month in seawater at 20 degrees C, no significant differences were observed between the behaviors of GFP-VLPs and of infectious rotavirus, whereas pseudovirus particles showed a higher decay rate. In the presence of 1 mg of free chlorine (FC)/liter both tracers persisted longer in freshwater at 20 degrees C than infectious viruses, whereas in the presence of 0.2 mg of FC/liter no differences were observed between tracers and infectious rotavirus at short contact times. However, from 30 min of contact with FC onward, the decay of infectious rotavirus was higher than that of recombinant particles. The predicted Ct value for a 90% reduction of GFP-VLPs or pseudoviruses induces a 99.99% inactivation of infectious rotavirus. Both tracers were more resistant to UV light irradiation than infectious rotavirus in fresh and marine water. The effect of UV exposure was more pronounced on pseudovirus than in GFP-VLPs. In all types of water, the UV dose to induce a 90% reduction of pseudovirus ensures a 99.99% inactivation of infectious rotavirus. Recombinant virus surrogates open new possibilities for the systematic validation of virus removal practices in actual field situations where pathogenic agents cannot be introduced.

Survival and heat resistance of Listeria monocytogenes after exposure to alkali and chlorine.

A strain of Listeria monocytogenes isolated from a drain in a food-processing plant was demonstrated, by determination of D values, to be more resistant to the lethal effect of heat at 56 or 59 degrees C following incubation for 45 min in tryptose phosphate broth (TPB) at pH 12.0 than to that of incubation for the same time in TPB at pH 7.3. Cells survived for at least 6 days when they were suspended in TPB at pHs 9.0, 10.0, and 11.0 and stored at 4 or 21 degrees C. Cells of L. monocytogenes incubated at 37 degrees C for 45 min and then stored for 48 or 144 h in TPB at pH 10.0 were more resistant to heat treatment at 56 degrees C than were cells stored in TPB at pH 7.3. The alkaline-stress response in L. monocytogenes may induce resistance to otherwise lethal thermal-processing conditions. Treatment of cells in 0.05 M potassium phosphate buffer (pH 7.00 +/- 0.05) containing 2.0 or 2.4 mg of free chlorine per liter reduced populations by as much as 1.3 log(10) CFU/ml, while treatment with 6.0 mg of free chlorine per liter reduced populations by as much as 4.02 log(10) CFU/ml. Remaining subpopulations of chlorine-treated cells exhibited some injury, and cells treated with chlorine for 10 min were more sensitive to heating at 56 degrees C than cells treated for 5 min. Contamination of foods by L. monocytogenes cells that have survived exposure to processing environments ineffectively cleaned or sanitized with alkaline detergents or disinfectants may have more severe implications than previously recognized. Alkaline-pH-induced cross-protection of L. monocytogenes against heat has the potential to enhance survival in minimally processed as well as in heat-and-serve foods and in foods on holding tables, in food service facilities, and in the home. Cells surviving exposure to chlorine, in contrast, are more sensitive to heat; thus, the effectiveness of thermal processing in achieving desired log(10)-unit reductions is not compromised in these cells.

Postharvest Decay Risk Associated with Hydrocooling Tomatoes.

Tomatoes (breaker stage) hydrocooled with a cell suspension of Erwinia carotovora subsp. carotovora containing 50 to 200 mg of free chlorine per liter (ppm) (10°C, pH 7) remained decay free during a 10-day storage at 20°C. Sporadic disease appeared during storage of tomatoes similarly cooled with chlorinated water containing spores of Rhizopus stolonifer. In contrast, when chlorine was omitted from the pathogen suspensions, 50 to 100% of the fruit became diseased. A laboratory-scale shower hydrocooler reduced fruit temperatures from 35 to 15°C within 13.3 min, whereas a flume cooler produced the same temperature reduction in 10.5 min. In both systems, tomatoes increased in weight during cooling, evidence for water uptake. Larger weight increases occurred among tomatoes cooled in the shower than in the flume. An upward instead of downward orientation of stem scars under the shower streams led to significantly larger weight increases, presumably because pores in the stem scar were continuously flooded with water. Tomatoes intermittently submerged in cold water (10 2-min immersions followed by 30-s pauses) absorbed significantly less water than those continuously submerged for 20 min. Hydrocooling appears to be a viable method for rapid cooling of tomatoes. Technical refinements in the hydrocooling process that prevent continuous coverage of fruit surfaces by water should reduce water uptake and the associated risk of pathogen internalization. Maintenance of free chlorine at up to 200 ppm in the cooling water and prevention of direct water pressure on fruit should minimize decay risks. No evidence of phytotoxicity was observed among fruit infiltrated with 200 ppm of chlorine. These tomatoes ripened similarly to those that were not cooled or were cooled in tap water.

Use of integrated cell culture-PCR to evaluate the effectiveness of poliovirus inactivation by chlorine.

Current standards, based on cell culture assay, indicate that poliovirus is inactivated by 0.5 mg of free chlorine per liter after 2 min; however, integrated cell culture-PCR detected viruses for up to 8 min of exposure to the same chlorine concentration, requiring 10 min for complete inactivation. Thus, the contact time for chlorine disinfection of poliovirus is up to five times greater than previously thought.

An Assessment of the Decay Hazard Associated with Hydrocooling Strawberries

The decay hazard associated with hydrocooling strawberries was related to whether they became inoculated with postharvest pathogens during the procedure. Storage of hydrocooled berries at warmer temperatures or for longer periods than recommended allowed inoculation to be expressed into disease. Cooling strawberries by immersion hydrocooling did not consistently lead to increased postharvest decays when compared with conventional forced-air cooling in two separate trials. No differences in decay incidence were found in berries that were hydrocooled versus forced-air cooled and then stored 7 days at 1°C plus 1 day at 20°C. With a 15-day storage regime (14 days at ≤7°C plus 1 day at 20°C), hydrocooled fruit developed less decay than forced-air-cooled fruit in one trial but more decay in a second. Wrapping baskets of cooled berries with plastic film promoted disease development and slowed the moisture loss from both hydrocooled and forced-air-cooled berries. The wrap did not promote disease more when applied to wet, hydrocooled berries as compared with dry, forced-air-cooled berries. Residual moisture left on the berries by the hydrocool treatment did not predispose the fruit to postharvest decays. In contrast, wounds and abrasions on hydrocooled fruit were temporarily water soaked and berries typically increased in weight as they were hydrocooled. Berries cooled in water containing spores of Botrytis cinerea or Rhizopus stolonifer developed nearly 100% decay incidence during a storage regime that favored specific development of gray mold (11 days at 7°C) or Rhizopus rot (2 days at 24°C). Chlorinating the hydrocooler water (120 mg of free chlorine per liter at pH 6.5) before adding the berries and spores reduced the incidence of gray mold to 43%; in contrast, berries hydrocooled in clean water developed 61% gray mold. Chlorination of the clean water led to significant reductions in the incidence of gray mold (44%) but did not affect the incidence of Rhizopus rot. The hydrocool method for cooling strawberries with the addition of proper chlorination has promise as a rapid method for cooling and cleaning berries and reducing gray mold inoculum on berry surfaces.

Oxidation-Reduction Potential of Chlorine Solutions and Their Toxicity toErwinia carotovorasubsp,carotovoraandGeotrichum candidum

The toxicity of chlorine solutions to cells of Erwinia carotovora subsp. carotovora and conidia of Geotrichum candidum suspended in water at pH 6.0, 7.0, or 8.0 was correlated with the free chlorine concentration and oxidation-reduction potential of the solutions. The oxidation-reduction potential was directly correlated with the Log 10 of the chlorine concentration at each pH. Cells of E. c. carotovora were 50 times more sensitive to chlorine than were conidia of G, candidum, with populations of 1 × 10 7 cfu/ml and 1 × 10 7 conidia per milliliter, respectively, Populations of E. c, carotovora were reduced below detectable levels (< 10 2 cfu/ml) by approximately 0,5, 0,5, or 0,75 mg of free chlorine per liter at pH 6.0, 7.0, or 8.0, respectively. In contrast, with conidia of G. candidum, 25, 25, and greater than 30 mg/L, respectively, were required to produce a similar level of efficacy. With both organisms, population reductions were associated with higher initial oxidation-reduction potentials at pH 6.0 than at pH 8.0

Cell culture and PCR determination of poliovirus inactivation by disinfectants

Inactivation of poliovirus type 1 by 1 N HCl, 1 N NaOH, 0.5 and 1.0 mg of free chlorine per liter, and UV light was compared by using cell culture and seminested PCR (30 cycles of reverse transcriptase-PCR plus 30 cycles of seminested PCR). A minimum contact time of 45 min with HCl, 3 min with NaOH, 3 and 6 min with 1.0 and 0.5 mg of free chlorine per liter, respectively, was required to render 1.64 x 10(2) PFU of poliovirus type 1 per ml undetectable by seminested PCR. In cell culture, a minimum contact time of 5 min to HCl, 30 s to NaOH, and 1 min to either chlorine concentration was required to render the viruses undetectable by the plaque assay method. No correlation was observed between results by PCR and cell culture when viruses were exposed to UV light. These data suggest that inactivated virus with intact nucleic acid sequences can be detected by PCR.

Disinfection of human enteric viruses in water by copper and silver in combination with low levels of chlorine

The efficacy of copper and silver ions, in combination with low levels of free chlorine (FC), was evaluated for the disinfection of hepatitis A virus (HAV), human rotavirus (HRV), human adenovirus, and poliovirus (PV) in water. HAV and HRV showed little inactivation in all conditions. PV showed more than a 4 log10 titer reduction in the presence of copper and silver combined with 0.5 mg of FC per liter or in the presence of 1 mg of FC per liter alone. Human adenovirus persisted longer than PV with the same treatments, although it persisted significantly less than HRV or HAV. The addition of 700 micrograms of copper and 70 micrograms of silver per liter did not enhance the inactivation rates after the exposure to 0.5 or 0.2 mg of FC per liter, although on some occasions it produced a level of inactivation similar to that induced by a higher dose of FC alone. Virus aggregates were observed in the presence of copper and silver ions, although not in the presence of FC alone. Our data indicate that the use of copper and silver ions in water systems may not provide a reliable alternative to high levels of FC for the disinfection of viral pathogens. Gene probe-based procedures were not adequate to monitor the presence of infectious HAV after disinfection. PV does not appear to be an adequate model viral strain to be used in disinfection studies. Bacteroides fragilis bacteriophages were consistently more resistant to disinfection than PV, suggesting that they would be more suitable indicators, although they survived significantly less than HAV or HRV.

Assessment of the bacteriological activity associated with granular activated carbon treatment of drinking water

Bacteriological analyses were performed on the effluent from a conventional water treatment pilot plant in which granular activated carbon (GAC) had been used as the final process to assess the impact of GAC on the microbial quality of the water produced. Samples were collected twice weekly for 160 days from the effluents of six GAC columns, each of which used one of four different empty-bed contact times (7.5, 15, 30, and 60 min). The samples were analyzed for heterotrophic plate counts and total coliforms. Effluent samples were also exposed to chloramines and free chlorine for 60 min (pH 8.2, 23 degrees C). Bacterial identifications were performed on the disinfected and nondisinfected effluents. Additional studies were conducted to assess the bacteriological activity associated with released GAC particles. The results indicated that heterotrophic plate counts in the effluents from all columns increased to 10(5) CFU/ml within 5 days and subsequently stabilized at 10(4) CFU/ml. The heterotrophic plate counts did not differ at different empty-bed contact times. Coliforms (identified as Enterobacter spp.) were recovered from the nondisinfected effluent on only two occasions. The disinfection results indicated that 1.5 mg of chloramines per liter inactivated approximately 50% more bacteria than did 1.0 mg of free chlorine per liter after 1 h of contact time. Chloramines and chlorine selected for the development of different bacterial species--Pseudomonas spp. and Flavobacterium spp., respectively.(ABSTRACT TRUNCATED AT 250 WORDS)

Efficacy of copper and silver ions and reduced levels of free chlorine in inactivation of Legionella pneumophila.

Water disinfection systems utilizing electrolytically generated copper and silver ions (200 and 20, 400 and 40, or 800 and 80 micrograms/liter) and low levels of free chlorine (0.1 to 0.4 mg/liter) were evaluated at room (21 to 23 degrees C) and elevated (39 to 40 degrees C) temperatures in filtered well water (pH 7.3) for their efficacy in inactivating Legionella pneumophila (ATCC 33155). At room temperature, a contact time of at least 24 h was necessary for copper and silver (400 and 40 micrograms/liter) to achieve a 3-log10 reduction in bacterial numbers. As the copper and silver concentration increased to 800 and 80 micrograms/liter, the inactivation rate significantly (P less than or equal to 0.05) increased from K = 2.87 x 10(-3) to K = 7.50 x 10(-3) (log10 reduction per minute). In water systems with and without copper and silver (400 and 40 micrograms/liter), the inactivation rates significantly increased as the free chlorine concentration increased from 0.1 mg/liter (K = 0.397 log10 reduction per min) to 0.4 mg/liter (K = 1.047 log10 reduction per min). Compared to room temperature, no significant differences were observed when 0.2 mg of free chlorine per liter with and without 400 and 40 micrograms of copper and silver per liter was tested at 39 to 40 degrees C. All disinfection systems, regardless of temperature or free chlorine concentration, showed increase inactivation rates when 400 and 40 micrograms of copper and silver per liter was added; however, this trend was significant only at 0.4 mg of free chlorine per liter.

Inactivation of Campylobacter jejuni by chlorine and monochloramine.

Campylobacter jejuni and closely related organisms are important bacterial causes of acute diarrheal illness in the United States. Both endemic and epidemic infections have been associated with consuming untreated or improperly treated surface water. We compared susceptibility of three C. jejuni strains and Escherichia coli ATCC 11229 with standard procedures used to disinfect water. Inactivation of bacterial preparations with 0.1 mg of chlorine and 1.0 mg of monochloramine per liter was determined at pH 6 and 8 and at 4 and 25 degrees C. Under virtually every condition tested, each of the three C. jejuni strains was more susceptible than the E. coli control strain, with greater than 99% inactivation after 15 min of contact with 1.0 mg of monochloramine per liter or 5 min of contact with 0.1 mg of free chlorine per liter. Results of experiments in which an antibiotic-containing medium was used suggest that a high proportion of the remaining cells were injured. An animal-passaged C. jejuni strain was as susceptible to chlorine disinfection as were laboratory-passaged strains. These results suggest that disinfection procedures commonly used for treatment of drinking water to remove coliform bacteria are adequate to eliminate C. jejuni and further correlate with the absence of outbreaks associated with properly treated water.

Chlorine resistance patterns of bacteria from two drinking water distribution systems

The relative chlorine sensitivities of bacteria isolated from chlorinated and unchlorinated drinking water distribution systems were compared by two independent methods. One method measured the toxic effect of free chlorine on bacteria, whereas the other measured the effect of combined chlorine. Bacteria from the chlorinated system were more resistant to both the combined and free forms of chlorine than those from the unchlorinated system, suggesting that there may be selection for more chlorine-tolerant microorganisms in chlorinated waters. Bacteria retained on the surfaces of 2.0-microns Nuclepore membrane filters were significantly more resistant to free chlorine compared to the total microbial population recovered on 0.2-micron membrane filters, presumably because aggregated cells or bacteria attached to suspended particulate matter exhibit more resistance than unassociated microorganisms. In accordance with this hypothesis, scanning electron microscopy of suspended particulate matter from the water samples revealed the presence of attached bacteria. The most resistant microorganisms were able to survive a 2-min exposure to 10 mg of free chlorine per liter. These included gram-positive spore-forming bacilli, actinomycetes, and some micrococci. The most sensitive bacteria were readily killed by chlorine concentrations of 1.0 mg liter-1 or less, and included most gram-positive micrococci, Corynebacterium/Arthrobacter, Klebsiella, Pseudomonas/Alcaligenes, Flavobacterium/Moraxella, and Acinetobacter.