Linear Dodecyl Benzene Sulfonic Acid Research Articles

Application of surfactants on asphaltene stability in heavy oil by interfacial tension approach

ABSTRACT The objective of this work is to understand the effect of asphaltene on surface properties including interfacial tension (IFT) and reach a specific surfactant in order to inhibit asphaltene precipitation in heavy oils. IFT experiments are implemented by Pendant Drop method and effective mechanisms causing IFT fluctuations are interpreted. The uniform trend of IFT for water/synthetic oil diminished at 25 volume percent of n-heptane which is attributed to asphaltene precipitation onset. Repetition of the experiment with 31 volume percent of n-heptane and real oil sample of field “S” resulted in asphaltene precipitation onset point. This change is justified by different density of synthetic and real oil samples. In addition, three surfactants of L-DBSA (linear dodecyl-benzene-sulfonic acid), B-DBSA (branched dodecyl-benzene-sulfonic acid), and DR (dodecyl resorcinol) are used to retard the asphaltene precipitation onset. Due to special chemical structure and polar group of DR, it is a weaker surfactant than DBSA in terms of inhibition of asphaltene precipitation. Furthermore, chemical structure and spatial avoidance of branches in B-DBSA causes little adsorption to asphaltene molecules and insignificant stability that eventually postpones the onset of asphaltene precipitation at lower degree compared to L-DBSA. When surfactants are introduced, the thin film of asphaltene formed on water-oil interface exhibits enhanced stability with the order of L-DBSA>B-DBSA>DR. Results show 0.25 wt% of L-DBSA can considerably delay the onset point that remedies the problem of asphaltene precipitation in heavy oil fields to great extent.

Identification of factors influencing teat dip efficacy trial results by meta-analysis.

Two meta-analyses were conducted using data from peer-reviewed natural exposure (NE) and experimental challenge (EC) teat dip efficacy trials to identify factors influencing the new intramammary infection (IMI) rate. A NE data set containing 16 studies and an EC data set containing 21 studies were created. New IMI rate was calculated based on the percentage of new quarter infections per month (PNQI/mo) for each observation, in both data sets, and used as the dependent variable for model derivation. A linear, mixed-effects model with a random study effect, weighted by number of quarters eligible for infection, was derived for each data set. The final NE model included the effects of experimental design (split herd or split udder), mastitis pathogen group (Staphylococcus aureus, Streptococcus agalactiae, environmental streptococci, gram-negative species, Corynebacterium spp., or coagulase-negative staphylococci), postmilking treatment (iodine, chlorhexidine, linear dodecyl benzene sulfonic acid, chlorine compounds, phenol compounds, or undipped negative controls), and the interaction between mastitis pathogen group and postmilking treatment. Overall, Corynebacterium spp. had the highest new IMI rate (0.0139±0.0018 PNQI/mo), and environmental streptococci and gram-negative species had the lowest (0.0023±0.0022 PNQI/mo). Additionally, trials utilizing a split herd experimental design had a 2-fold higher new IMI rate than trials using a split udder design. The final EC model included the effects of mastitis pathogen (Staph. aureus and Strep. agalactiae), postmilking treatment (iodine, chlorine compounds, "other" active ingredients, or undipped negative controls), geographic region of study (Eastern, Southern, and Pacific Northwest), and the 2-way interactions of region and pathogen group and postmilking treatment and pathogen group. Overall, Staph. aureus and Strep. agalactiae had similar new IMI rates. Quarters dipped postmilking in either iodine (0.0127±0.0099 PNQI/mo), chlorine compounds (0.0258±0.0095 PNQI/mo), or "other" active ingredient teat dips (0.0263±0.0106 PNQI/mo) had lower new IMI rates than undipped quarters (0.0859±0.0087 PNQI/mo). These results indicate that experimental design influences the new IMI rate of teat dip efficacy trials and that using an effective postmilking teat dip has a greater effect on controlling the new Staph. aureus and Strep. agalactiae IMI rate than the teat dip's active ingredient.

Dynamic surface tension of coal-water slurry fuels

Experiments were conducted to measure the dynamic surface tension of coal-water slurry (CWS) mixtures containing various types of surfactants and with different coal loadings. A maximum air bubble pressure technique measured the dynamic surface tension. The coal used for the CWS had 55 μm volume mean diameter (VMD) and was mined from the Upper Elkhorn seam, Virginia. Five surfactants were selected for the study: one non-ionic alkylphenol ethoxylate (NP-100), and four anionic surfactants; branched dodecylbenzene sulfonic acid (DDBS-hard), linear dodecylbenzene sulfonic acid (DDBS-soft), a sodium salt of a branched alkylbenzene sulfonic acid (1223H), and a sodium salt of sulfonated fatty acid (1840X). To determine the critical micelle concentration (CMC), the static surface tension was also measured using a du Nouy ring tensiometer. Measured values of dynamic surface tension are presented for 40 and 50% CWS mixtures, with surfactant concentrations ranging from 0.1 to 5.0% in weight.

In Vitro Germicidal Activity of Teat Dips Against Nocardia asteroides and Other Udder Pathogens

Nine commercial teat dip formulations containing 1.94% linear dodecylbenzene sulfonic acid, or 1% available iodine from nonylphenoxypoly (ethyleneoxy) ethanol-iodine complex, or .5% chlorhexidine acetate were tested for contamination with aerobic and anaerobic bacteria and their in vitro germicidal activity against Staphylococcus aureus, Streptococcus agalactiae, Escherichia coli, and Nocardia asteroides. All products were free of bacteria when neutralized samples were tested on blood agar or liquid thioglycollate media. To test for in vitro efficacy, each teat dip preparation was mixed with a suspension of one of the pathogenic test organisms containing 108 bacteria/ml (final concentration) for .5 to 15min. Viable bacteria were evaluated by direct plating of neutralized aliquots and by filtration techniques. All products were effective against E. coli, Staph. aureus, and Strep. agalactiae. With N. asteroides, the direct plating method gave equivocal results. The filtration experiments indicated that all teat dips containing dodecylbenzene sulfonic acid and nonylphenoxypoly (ethyleneoxy) ethanol-iodine complex were effective against all four pathogens. Three of the teat dips containing chlorhexidine acetate were ineffective against N. asteroides. The fourth teat dip, containing chlorhexidine acetate and an emollient, was partially effective.

Effects of a 1.94% Sulfonic Acid Teat Dip and a 1% Iodophor Teat Dip on Teat Canal Infections in Lactating Dairy Cows

Sixty-three cows were used in a natural exposure trial for 1 yr to determine the effects of a 1.94% linear dodecyl benzene sulfonic acid and a 1% iodophor teat dip on teat canal and intramammary infections. Overall, total teat canal infections increased 28.9% and total intramammary infections increased 30% in quarters dipped with the linear dodecyl benzene sulfonic acid compared with a 14.3% increase in teat canal infections and a 17.4% decrease in intramammary infections for the iodophor group. Higher frequencies were observed for teat canal and intramammary infections caused by Staphylococcus epidermidis in the linear dodecyl benzene sulfonic acid group. Stephylococcus hyicus was the predominant organism isolated from teat canal and intramammary infections in the iodophor group. No difference was observed between the two teat dips in the persistence of Staphylococcus aureus canal infections. A greater number of S. hyicus canal infections persisted in the iodophor group, whereas teat canal infections produced by S. epidermidis and Staphylococcus xylosus persisted longer in the sulfonic acid group. Results of this study indicated that use of a linear dodecyl benzene sulfonic acid teat dip for 1 yr was not associated with increased S. aureus teat canal infections and intramammary infections. However, linear dodecyl benzene sulfonic acid appeared to affect the distribution of coagulase-negative staphylococci isolated from teat canal infections and intramammary infections.

Prolonged In Vitro Exposure of Staphylococcus aureus to Germicidal Teat Dips

Eight strains of Staphylococcus aureus were tested to determine if prolonged exposure to commercial teat dips could enhance bacterial tolerance to teat dips in vitro. All strains of S. aureus were serially plated 15 times on chemically defined agar medium containing sublethal concentrations of linear dodecyl benzene sulfonic acid, chlorhexidine, sodium hypochlorite, and iodophor teat dips. Growth responses of S. aureus to chlorhexidine, sodium hypochlorite, and iodophor were not affected by prolonged exposure to these teat dips. Isolates subcultured on agar containing .1% linear dodecyl benzene sulfonic acid teat dip subsequently had a greater mean growth response to .1% solution of the germicide than did controls subcultured on basal medium. Hemolytic patterns, tube coagulase, clumping factor, and protein A reactions of S. aureus were not altered by exposure to any of the teat dips tested. In general, prolonged exposure to commercial teat dips did not alter germicidal susceptibility of S. aureus.

Effects of Teat Dipping on Intramammary Infections by Staphylococci other than Staphylococcus aureus

Effects on intramammary infections in herds 1) either not teat dipping or postmilking teat dipping with either 2) linear dodecyl benzene sulfonic acid, 3) chlorhexidine, or 4) iodophor containing products were determined.Duplicate quarter foremilk samples were collected once from all lactating cows in 16 herds, four for each practice. Mean percentage of quarters infected with Staphylococcus species other than Staph. aureus was 11.0 in herds not teat dipping and 7.2 in herds teat dipping. Prevalence of Staphylococcus species intramammary infections in herds teat dipping with linear dodecyl benzene sulfonic acid was comparable to herds not teat dipping and greater than in herds using chlorhexidine and iodophor. The predominant Staphylococcus species in herds not teat dipping was Staph. epidermidis (37.1%). Staphylococcus hyicus constituted 48.5% of total Staphylococcus species intramammary infections in herds teat dipping and 12.4% in herds not teat dipping. Differences were not observed among SCC for quarters infected with different Staphylococcus species. Application of germicidal teat dips appeared to have selectively altered both prevalence and distribution of Staphylococcus species intramammary infections.

Field Studies on Linear Dodecyl Benzene Sulfonic Acid Teat Dip

A teat dip containing 1.94% linear dodecyl benzene sulfonic acid and 12% glycerine33Blu-Gard, Economics Laboratory, Inc., St. Paul, MN 55102., an anionic detergent formulation, was evaluated in two field trials on a commercial dairy. In Trial 1, the teat dip was compared to an undipped control in a split-herd design. Incidence of infection with Streptococcus agalactiae was reduced 57.8%; infections with presumptively identified Staphylococcus aureus were not reduced. Milking machine function and milking procedures may have affected teat dip effectiveness and incidence of udder infection. Streptococcus agalactiae was eradicated prior to Trial 2 in which the detergent teat dip was compared to a 1% iodophor product44Udder Guard, Economics Laboratory, Inc., St. Paul, MN 55102. of proven efficacy. Incidence of Staphylococcus aureus infection was 40.5% lower in the detergent than in the iodophor group. Taxonomic studies on Staphylococcus species indicated that presumptive microbial identification resulted in erroneous conclusions concerning efficacy of the teat dip products. Importance of speciation of staphylococcal isolates is discussed.

Efficacy Evaluation of Two New Teat Dip Formulations Under Experimental Challenge

Two new teat dip formulations were evaluated against Streptococcus agalactiae and Staphylococcus aureus in half-udder, experimental challenge studies. The first product contained a combination of 1.9% linear dodecyl benzene sulfonic acid— .55% iodophor.1 Incidence of infection was reduced 52.7 and 70.7% for Streptococcus agalactiae and Staphylococcus aureus in dipped quarters compared to undipped controls. The second formulation was a barrier-type product consisting of milk protein solubilized with lauryl sulfate, a surface active detergent and 4.8% glycerin. Rates of infection were reduced 60.3 and 67.9% for Streptococcus agalactiae and Staphylococcus aureus.

Germicidal Persistence of Teat Dips by Modified Excised Teat Procedure

An excised teat protocol was modified to evaluate persistence of germicidal activity of teat dips over 8h. Five teat dip formulations, iodophor (1%), chlorhexidine gluconate (.55%), linear dodecyl benzene sulfonic acid (1.94%), sodium chlorite-lactic acid in a water base, and sodium chlorite-lactic acid in a gel base were tested against Escherichia coli and Klebsiella oxytoca. Iodophor and chlorhexidine had high germicidal activity throughout 8h, whereas dodecyl benzene sulfonic acid had little activity. Germicidal activity of both sodium chlorite-lactic acid teat dips was high initially but declined with time. The gel base dip, however, remained more germicidal than the water base dip. Results were similar for either organism for most teat dips. However, chlorhexidine was less effective and the gel base dip more effective against Klebsiella oxytoca than Escherichia coli. Standard errors often appeared higher for Klebsiella oxytoca than for Escherichia coli. These assays may prove useful for laboratory screening of teat dips to determine germicidal persistence over time.

Evaluation of Linear Dodecyl Benzene Sulfonic Acid as a Teat Dip in a Commercial Dairy

A postmilking teat dip containing 1.94% linear dodecyl benzene sulfonic acid1 was evaluated for approximately 6 mo on a commercial dairy farm that milked an average of 75 cows. Sixteen Staphylococcus aureus infections were diagnosed, 12 in the undipped control quarters and 4 in the dipped. Incidence of intramammary infection with Staphylococcus aureus was reduced 68.1%. Seventy-five infections were diagnosed as micrococci, 42 in control and 33 in the dipped group, a 23.6% reduction. A total of 37 Corynebacterium sp. infections were diagnosed, 21 and 16 in control and dipped groups, a 25.8% reduction. Teat skin condition did not change during the study.