FMDV Challenge Research Articles

Calcium Chloride as a Novel Stabilizer for Foot-and-Mouth Disease Virus and Its Application in the Vaccine Formulation.

The thermal stability of the in-house-developed foot-and-mouth disease (FMD) type O and A viruses was evaluated, and the O Jincheon virus was found to exhibit the lowest thermal stability. To overcome this instability, we proposed a novel stabilizer, calcium chloride. The thermal stability of FMDVs increased up to a CaCl2 concentration of 10 mM, and it had a decreasing trend at >30 mM. The O Jincheon virus showed a significant decrease in the amount of antigen over time at 4 °C. In contrast, the samples treated with CaCl2 showed stable preservation of the virus without significant antigen loss. After the CaCl2-formulated vaccine was administered twice to pigs, the virus neutralization titer reached approximately 1:1000, suggesting that the vaccine could protect pigs against the FMDV challenge. In summary, the O Jincheon virus is difficult to utilize as a vaccine given its low stability during storage after antigen production. However, following its treatment with CaCl2, it can be easily utilized as a vaccine. This study evaluated CaCl2 as a novel stabilizer in FMD vaccines and may contribute to the development of stable vaccine formulations, especially for inherently unstable FMDV strains.

Antiviral Activity Of Adamantane-Pyrazole Derivatives Against Foot And Mouth Disease Virus Infection In Vivo And In Vitro With Molecular Docking Study

Foot-and-mouth disease (FMD) vaccine does not afford early effective protection until adaptive immune protection caused by the vaccination occurs. Therefore, an alternative prophylactic application of antiviral agents for inhibition of the FMD virus is needed, and this is the scope of this study. In this study, we tested nine adamantane-pyrazole derivatives that could exhibit antiviral activity against FMDV infection either in vitro through baby hamster kidney cells (BHK-21 cells) infected with FMD virus serotypes O pan Asia. Cytotoxicity Concentration 50 (CC50) activity of pyrazole derivatives (1, 2, 3, 4, 5a,b, 6a-c) were detected on BHK-21 cells and ranged between 500 to 3000µg/ml. Inhibitory Concentration 50 (IC50) on BHK-21 was achieved only for the most promising three derivatives 6a-c and exhibited an antiviral activity with a therapeutic index of 30, and that was reflected on the antiviral activity response in baby mice with different concentrations where a concentration of 50 µg/ml for pyrazole derivatives 6a and 6c compounds and 40 µg/ml for bis-tolyl pyrazole 6b that achieve 100% protection and this results was as effective as 50 µg/ml of amantadine. Specifically, diaryl pyrazole derivatives 6a-c that protected for six days following FMDV challenge. These results suggested that pyrazole derivatives 6a-c could be used as an effective antiviral agent against FMD virus infection. Molecular docking simulation of the target compounds 6a-c had good binding energy and the tested compounds recommended being an excellent 3C protease inhibitor compared to Amantadine and Ribavirin. These findings may explain the antiviral activity of the target compounds.

Constitutively Active IRF7/IRF3 Fusion Protein Completely Protects Swine against Foot-and-Mouth Disease.

Foot-and-mouth disease (FMD) remains one of the most devastating livestock diseases around the world. Several serotype-specific vaccine formulations exist, but they require about 5 to 7 days to induce protective immunity. Our previous studies have shown that a constitutively active fusion protein of porcine interferon (IFN) regulatory factors (IRF) 7 and 3 [IRF7/3(5D)] strongly induced type I IFN and antiviral genes in vitro and prevented mortality in an FMD mouse model when delivered with a replication-defective adenoviral vector [Ad5-poIRF7/3(5D)]. Here, we demonstrate that pigs treated with 10(8), 10(9), or 10(10) PFU of Ad5-poIRF7/3(5D) 24 h before FMDV challenge were fully protected from FMD clinical signs and did not develop viremia, virus shedding or antibodies against FMDV nonstructural proteins. Pigs treated with Ad5-poIRF7/3(5D) had higher levels of IFN and antiviral activity in serum, and upregulated expression of several IFN-stimulated genes in peripheral blood mononuclear cells, compared to pigs treated with Ad5-Blue vector control. Importantly, treatment of porcine cultured cells with Ad5-poIRF7/3(5D) inhibited the replication of all 7 FMDV serotypes. In vitro experiments using cultured embryonic fibroblasts derived from IFN receptor knockout mice suggested that the antiviral response induced by Ad5-poIRF7/3(5D) was dependent on type I and III IFN pathways; however, experiments with mice demonstrated that a functional type I IFN pathway mediates Ad5-poIRF7/3(5D) protection conferred in vivo Our studies demonstrate that inoculation with Ad5-poIRF7/3(5D) completely protects swine against FMD by inducing a strong type I IFN response and highlights its potential application to rapidly and effectively prevent FMDV replication and dissemination. Foot-and-mouth disease virus (FMDV) causes a fast-spreading disease that affects farm animals, with economically and socially devastating consequences. Our study shows that inoculation with a constitutively active transcription factor, namely, a fusion protein of porcine interferon (IFN) regulatory factors (IRF) 7 and 3 delivered by an adenovirus vector [Ad5-poIRF7/3(5D)], is a new effective treatment to prevent FMD in swine. Animals pretreated with Ad5-poIRF7/3(5D) 1 day before being exposed to FMDV were completely protected from viral replication and clinical disease. It is noteworthy that the doses of Ad5-poIRF7/3(5D) required for protection are lower than those previously reported for similar approaches using Ad5 vectors delivering type I, II, or III IFN, suggesting that this novel strategy would be economically appealing to counteract FMD. Our results also indicate that a dynamic interplay among different components of pigs' innate immune defenses allows potent antiviral effects after Ad5-poIF7/3(5D) administration.

Novel 6xHis tagged foot-and-mouth disease virus vaccine bound to nanolipoprotein adjuvant via metal ions provides antigenic distinction and effective protective immunity

Here, we engineered two FMD viruses with histidine residues inserted into or fused to the FMDV capsid. Both 6xHis viruses exhibited growth kinetics, plaque morphologies and antigenic characteristics similar to wild-type virus. The 6xHis tag allowed one-step purification of the mutant virions by Co2+ affinity columns. Electron microscopy and biochemical assays showed that the 6xHis FMDVs readily assembled into antigen: adjuvant complexes in solution, by conjugating with Ni2+-chelated nanolipoprotein and monophosphoryl lipid A adjuvant (MPLA:NiNLP). Animals Immunized with the inactivated 6xHis-FMDV:MPLA:NiNLP vaccine acquired enhanced protective immunity against FMDV challenge compared to virions alone. Induction of anti-6xHis and anti-FMDV neutralizing antibodies in the immunized animals could be exploited in the differentiation of vaccinated from infected animals needed for the improvement of FMD control measures. The novel marker vaccine/nanolipid technology described here has broad applications for the development of distinctive and effective immune responses to other pathogens of importance.

Foot-and-mouth disease virus-like particles produced by a SUMO fusion protein system in Escherichia coli induce potent protective immune responses in guinea pigs, swine and cattle

Foot-and-mouth disease virus (FMDV) causes a highly contagious infection in cloven-hoofed animals. The format of FMD virus-like particles (VLP) as a non-replicating particulate vaccine candidate is a promising alternative to conventional inactivated FMDV vaccines. In this study, we explored a prokaryotic system to express and assemble the FMD VLP and validated the potential of VLP as an FMDV vaccine candidate. VLP composed entirely of FMDV (Asia1/Jiangsu/China/2005) capsid proteins (VP0, VP1 and VP3) were simultaneously produced as SUMO fusion proteins by an improved SUMO fusion protein system in E. coli. Proteolytic removal of the SUMO moiety from the fusion proteins resulted in the assembly of VLP with size and shape resembling the authentic FMDV. Immunization of guinea pigs, swine and cattle with FMD VLP by intramuscular inoculation stimulated the FMDV-specific antibody response, neutralizing antibody response, T-cell proliferation response and secretion of cytokine IFN-γ. In addition, immunization with one dose of the VLP resulted in complete protection of these animals from homologous FMDV challenge. The 50% protection dose (PD50) of FMD VLP in cattle is up to 6.34. These results suggest that FMD VLP expressed in E. coli are an effective vaccine in guinea pigs, swine and cattle and support further development of these VLP as a vaccine candidate for protection against FMDV.

Montanide ISA™ 201 adjuvanted FMD vaccine induces improved immune responses and protection in cattle

Despite significant advancements in modern vaccinology, inactivated whole virus vaccines for foot-and-mouth disease (FMD) remain the mainstay for prophylactic and emergency uses. Many efforts are currently devoted to improve the immune responses and protective efficacy of these vaccines. Adjuvants, which are often used to potentiate immune responses, provide an excellent mean to improve the efficacy of FMD vaccines. This study aimed to evaluate three oil adjuvants namely: Montanide ISA-201, ISA-206 (SEPPIC, France) and GAHOL (an in-house developed oil-adjuvant) for adjuvant potential in inactivated FMD vaccine. Groups of cattle (n=6) were immunized once intramuscularly with monovalent FMDV ‘O’ vaccine formulated in these adjuvants, and humoral (serum neutralizing antibody, IgG1 and IgG2) and cellular (lymphoproliferation) responses were measured. Montanide ISA-201 adjuvanted vaccine induced earlier and higher neutralizing antibody responses as compared to the two other adjuvants. All the adjuvants induced mainly serum IgG1 isotype antibody responses against FMDV. However, Montanide ISA-201 induced relatively higher IgG2 responses than the other two adjuvants. Lymphoproliferative responses to recall FMDV antigen were relatively higher with Montanide ISA-201, although not always statistically significant. On homologous FMDV challenge at 30 days post-vaccination, 100% (6/6) of the cattle immunized with Montanide-201 adjuvanted vaccine were protected, which was superior to those immunized with ISA-206 (66.6%, 4/6) or GAHOL adjuvanted vaccine (50%, 3/6). Virus replication following challenge infection, as determined by presence of the viral genome in oropharynx and non-structural protein serology, was lowest with Montanide ISA-201 adjuvant. Collectively, these results indicate that the Montanide ISA-201 adjuvanted FMD vaccine induces enhanced immune responses and protective efficacy in cattle.

DNA prime-protein boost strategy with replicase-based DNA vaccine against foot-and-mouth disease in bovine calves

The limited efficacy of DNA vaccines against foot-and-mouth disease (FMD) in cattle and other natural hosts has prompted a search for a more effective vaccination regimen. In this study we tested a DNA prime-protein boost vaccination strategy against FMD in bovine calves. We used purified recombinant FMDV specific multi-epitope protein (rMEG990) and an optimized sindbis virus replicase-based DNA vaccine expressing this protein (pSinCMV-Vac-MEG990). We demonstrate that vaccination with a low dose of pSinCMV-Vac-MEG990 (10μg/animal) and subsequently boosting with rMEG990 resulted in induction of neutralizing antibodies, IFN-γ production and protection against homologous virus challenge. However, vaccination with a high dose of pSinCMV-Vac-MEG990 (100μg/animal) and boosting with rMEG990 resulted in significantly lower immune responses and more severity to the challenge test. Additionally, we show that the post-vaccinal IFN-γ levels in animals correlated positively to their protection against FMDV challenge. These findings suggest that a replicase-based DNA vaccine in proper prime-boost combination may offer an efficient vaccine strategy against FMDV and that IFN-γ could be used as an additional immune parameter to predict protection against FMDV infection.

Upconversion nanoparticles modified with aminosilanes as carriers of DNA vaccine for foot-and-mouth disease

The potential of the upconversion nanoparticles NaYF(4):Yb/Er@silica(UCPs)/plasmid DNA (pcDNA3.1/VP1-GFP) complex in inducing immune responses was evaluated using the UCPs as carriers of the foot-and-mouth disease virus (FMDV AsiaI/Jiangsu2005) DNA vaccine. The UCPs protection against DNaseI degradation was measured using an in vitro inhibition assay. The expression of the plasmid in vivo was determined via confocal microscopy. Its biocompatibility was evaluated through cytotoxicity assay. Based on the results, the aminosilane-modified UCPs can electrostatically bind, condense, and protect plasmid DNA. Cell viability assays demonstrated that the cytotoxicity of the UCPs/plasmid DNA complex is lower than that of the cationic lipid/plasmid DNA complex, and that the transfection efficiency of UCPs is the same as that of the cationic lipid. Furthermore, the UCP/plasmid DNA complex was intramuscularly administered to guinea pigs. Humoral and cellular immune responses were detected using indirect enzyme-linked immunosorbent assay (ELISA), micro-neutralization assay, and T-lymphocyte proliferation assay. Anti-FMDV specific antibodies, neutralizing antibodies, and T-lymphocyte proliferation responses were induced after vaccination. In the challenge test, all the guinea pigs vaccinated with the UCPs/plasmid DNA complex were fully protected from the FMDV challenge. The current study encourages the use of UCPs as an effective nanosystem for gene delivery to cells for in vitro and in vivo vaccination, and other therapeutic applications.

CpG oligodeoxynucleotide and montanide ISA 206 adjuvant combination augments the immune responses of a recombinant FMDV vaccine in cattle

Foot-and-mouth disease (FMD) is a highly contagious disease of cloven-hoofed animals. To prevent the spread of FMDV, inactivated virus vaccines are used to immunize animals in developing countries. However, there are safety concerns. In addition, it is difficult to distinguish the vaccinated animals from those naturally infected ones. In our lab, we have developed a recombinant FMDV vaccine named A7. A7 contained multiple B cell and T cell epitopes, which reside in a capsid protein (VP1) of FMDV. To enhance its immunogenicity, A7 was formulated with CpG ODN RW03 in combination with Montanide ISA 206 (ISA), and the resultant vaccine (A7+ISA+CpG ODN RW03) was used to immunize mice and cattle. It was found that CpG ODN RW03 and ISA combination could facilitate A7 to induce a vigorous and long-lasting specific antibody response in mice and cattle. After FMDV challenge, 80% (4/5) of the calves immunized with A7+ISA+CpG ODN RW03 were protected, which was superior to those immunized with A7+ISA (25%, 1/4) or inactivated FMDV vaccine (50%, 2/4). These findings suggest that CpG ODN RW03 could be used with Montanide ISA 206 as a potent adjuvant for recombinant FMDV in cattle.

DNA immunization of pigs with foot-and-mouth disease virus minigenes: From partial protection to disease exacerbation

Despite several attempts to design new vaccines, there are as of yet no available alternatives to the conventional FMDV vaccines. Here, we present the divergent results obtained in pigs after immunization with two experimental DNA vaccines encoding one B and two T cell FMDV epitopes, either expressed alone (pCMV-BTT) or fused to a strong signal peptide (pCMV-spBTT). While all pigs vaccinated with pCMV-spBTT showed both a delay in the disease onset and reduced severity of signs and lesions after FMDV challenge, pigs immunized with pCMV-BTT showed an exacerbation of the disease and most of the pigs remained viremic at 10 days post-infection, the end-point of the experiment, thus opening concerns about FMDV-suboptimal immunization. Interestingly, only one of the four pigs vaccinated with pCMV-spBTT showed neutralizing antibodies before challenge, demonstrating that partial protection against FMDV could be afforded in the absence of preexisting neutralizing antibodies.

Enhancing effects of the chemical adjuvant levamisole on the DNA vaccine pVIR-P12A-IL18-3C

DNA-based vaccination is an attractive alternative for overcoming the disadvantages of inactivated virus vaccines; however, DNA vaccines alone often generate only weak immune responses. In this study, the efficacy of LMS as a chemical adjuvant on a DNA vaccine (pVIR-P12A-IL18-3C) encoding the P1-2A and 3C genes of the FMDV and swine IL-18, which provides protection against FMDV challenge, was tested. All test pigs were administered booster vaccinations 28 days after the initial inoculation, and were challenged with 1000 ID50 FMDV O/NY00 20 days after the booster vaccination. Positive and negative control groups were inoculated with inactivated virus vaccine and PBS respectively. The DNA vaccine plus LMS induced greater humoral and cell-mediated responses than the DNA vaccine alone, as evidenced by higher concentrations of neutralizing and specific anti-FMDV antibodies, and by higher concentrations of T-lymphocyte proliferation and IFN-y production, respectively. FMDV challenge revealed that the DNA vaccine plus LMS provided higher protection than the DNA vaccine alone. This study demonstrates that LMS may be useful as an adjuvant for improving the protective efficiency of DNA vaccination against FMDV in pigs.

Immune responses of recombinant adenovirus co-expressing VP1 of foot-and-mouth disease virus and porcine interferon α in mice and guinea pigs

Foot-and-mouth disease (FMD) is a highly contagious and economically devastating vesicular disease of cloven-hoofed animals. In this study, we constructed and characterized the immune responses and vaccine efficacy conferred by the recombinant adenovirus co-expressing VP1 of FMDV and porcine interferon α as fusion protein (rAd-pIFNα-VP1). Six groups of female BALB/c mice each with 18 were inoculated subcutaneously twice 2-week intervals with the recombinant adenoviruses. The results showed that the levels of humoral and cell-mediated immune responses in the group inoculated with rAd-pIFNα-VP1 were significantly higher than those in the group inoculated with rAd-VP1 + rAd-pIFNα ( P < 0.05). Then four groups of guinea pigs each with six were inoculated two times at 2-week intervals intramuscularly with rAd-pIFNα-VP1, commercial inactivated FMD vaccine, wild-type adenovirus (wtAd) or PBS, and the protective efficacy of rAd-pIFNα-VP1 was determined. The results indicated that all the guinea pigs vaccinated with rAd-pIFNα-VP1 as well as inactivated FMD vaccine were protected from FMDV challenge, even though the levels of neutralizing antibodies (1:32–1:40) of the animals vaccinated with rAd-pIFNα-VP1 was lower than that in the group inoculated with inactivated FMD vaccine (1:64–1:128). It demonstrated that the newly recombinant adenovirus rAd-pIFNα-VP1 might further be an attractive candidate vaccine for preventing FMDV infection in swine.

Induction of protective immunity in swine by immunization with live attenuated recombinant pseudorabies virus expressing the capsid precursor encoding regions of foot-and-mouth disease virus

Foot-and-mouth disease (FMD) causes morbidity to livestock and serious economic consequences to its associated industry and therefore it is necessary to develop a safe and efficient vaccine to prevent or control this disease. A recombinant live attenuated virus vaccine, designated PRV-P1, was generated by insertion of an expression cassette containing CMV promoter, FMDV P1 gene and SV 40 poly-A into the gG gene region of a live attenuated pseudorabies virus vaccine strain (TK-/gG-/LacZ+). To determine the induction of protective immunity, 16 FMDV and PRV seronegative white swine were randomly divided into four groups and immunized intramuscularly. The parental virus (TK-/gG-/LacZ+) was injected into three pigs, the recombinant virus PRV-P1 into five pigs and commercial FMD-inactivated vaccine into five pigs, with PBS (negative control) into three pigs. All animals were immunized again 4 weeks later to boost the immune response and challenged with virulent type O FMDV O/ES/2001 strain 4 weeks after the second immunization. Results showed PRV-P1 vaccinated pigs induced high-level neutralizing antibody response to both FMDV and PRV, and strong CTL response against FMD antigen activation. Three of five pigs were completely protected against challenge with FMDV, one pig minimally protected and the other one had increased protection but not complete. However, one pig vaccinated with commercial FMD vaccine developed constant pyrexia. Average levels of antibodies against non-structural 3ABC proteins were significantly lower and efficacy on inhibition of FMDV replication was much increased in swine vaccinated with PRV-P1 than those immunized with commercial FMD vaccine after FMDV challenge. Our results showed that the recombinant PRV-P1 can induce not only humoral and cell-mediated immune responses but also partial protection against FMDV challenge, making it a good candidate for future development of the FMD vaccine.

Comparison of immune responses to different foot-and-mouth disease genetically engineered vaccines in guinea pigs

The P12A3C gene from FMDV (serotype O) encoding the capsid precursor protein, and the highly immunogenic gene FHG, which encodes multiple epitopes of FMDV capsid proteins, were inserted into eukaryotic expression vectors to compare different candidate genetically engineered vaccines for foot-and-mouth disease (FMD). A modified live pseudorabies virus (MLPRV) was also used to deliver P12A3C. Guinea pigs were inoculated intramuscularly with the candidate vaccines to compare the ability to elicit immunity of the DNA vector and a live viral vector. An indirect enzyme-linked immunosorbent assay (iELISA), virus-neutralization test and lymphoproliferation assay were used to detect antibody and cellular responses. The group immunized with P12A3C delivered by MLPRV produced significantly greater antibody and cellular responses indicating that MLPRV has a greater ability to mediate exogenous gene delivery than the plasmid DNA vector. Comparison of the immune responses induced by P12A3C and FHG, which were both mediated by DNA plasmids, showed that FHG and P12A3C elicited similar cellular responses, while P12A3C induced higher antibody levels, suggesting that P12A3C is a more powerful immunogen than FHG. In challenge experiments, guinea pigs vaccinated with P12A3C delivered by MLPRV were protected fully from FMDV challenge, whereas guinea pigs vaccinated with P12A3C or FHG delivered by DNA plasmid were only protected partially. This study provides a basis for future construction of a genetically engineered vaccine for FMDV.

Enhanced protective efficacy and reduced viral load of foot-and-mouth disease DNA vaccine with co-stimulatory molecules as the molecular adjuvants

To improve efficacy of DNA vaccination, various approaches have been developed, including the use of plasmid expressing co-stimulatory molecules as molecular adjuvants. In this study, we investigated whether co-inoculation of a construct expressing either 4-1BBL or OX40L as the molecular adjuvant with FMDV DNA vaccine, pcD-VP1, can increase immune responses and protective efficacies. Compared to the group immunized with pcD-VP1 alone, the co-inoculation of either molecular adjuvant induced a higher ratio of IgG2a/IgG1, higher levels of expression of IFN-γ in CD4 + and CD8 + T cells and antigen-specific CTL responses, and more importantly provided an enhanced protection against the live FMDV challenge in animals. Concurrently, 4-1BBL as the molecular adjuvant dramatically reduced the viral loads of FMDV in vivo after the challenge. Together, the results demonstrate that co-stimulatory molecules 4-1BBL and OX40L can enhance the antigen-specific cell-mediated responses elicited by VP1 DNA vaccine and provide an enhanced protective efficacy with the reduced viral loads.

Immune responses of pigs to commercialized emulsion FMD vaccines and live virus challenge

The immune response to structural and non-structural proteins (NSPs) was studied on sequential serum samples in swine from O/Taiwan/97 FMDV challenge studies, outbreaks and after vaccination. The results showed that pigs vaccinated with a commercial vaccine prior to or after infection maintained high neutralizing antibody titers with gradual decline from peak titers over the duration of this study. However, neutralizing antibody titers in non-vaccinated pigs only reached moderate levels 2–4 weeks post infection and remained low thereafter. For the 3B and 3ABC NSP antibody ELISA responses, there were gradually decreasing levels of NSP antibody over time. In multiple vaccinations, all pigs showed significant increases in neutralizing antibodies after booster vaccination. For the 3B NSP antibody ELISA after vaccination, the mean S/P ratios for pigs vaccinated with all three FMD vaccines were all below the 0.23 cut-off value set by the manufacture, but some sera from individual vaccinated pigs gave results above this cut-off after primary or secondary vaccination. However, with the 3ABC NSP antibody ELISA, all sera from vaccinated pigs had negative results for NSP antibody for all time points.

Immune response in guinea pigs vaccinated with DNA vaccine of foot-and-mouth disease virus O/China99

In order to obtain the gene P12X3C of foot-and-mouth disease virus (FMDV O/China99) that includes full length P1, 2A, 3C and part of 2B and 3B, the site mutation strategy was used. The recombinant plasmid pcDNA3.1/P12X3C was transfected into BHK-21 cells. The capsid proteins of FMDV expressed in BHK-21 cells were confirmed by sandwich-ELISA and indirect immunofluorescence test. Then the plasmid pcDNA3.1/P12X3C was administered to guinea pigs intramuscularly, and purified FMDV O/China993D protein expressed in yeast cells was injected together with pcDNA3.1/P12X3C. Anti-FMDV antibodies were detected by indirect ELISA, the T-lymphocyte proliferation response was tested by MTT assay, and neutralizating antibodies titers were analyzed by micro-neutralization assay. The result showed that the plasmid pcDNA3.1/P12X3C was able to express immunocompetent proteins of FMDV in BHK-21 cells. Furthermore, anti-FMDV antibodies were elicited and increased by plasmid pcDNA3.1/P12X3C in the second week after vaccination. Neutralizating antibodies were induced and the T-lymphocyte proliferation response was enhanced after vaccination. In the challenge test, all of guinea pigs vaccinated with pcDNA3.1/P12X3C were fully protected from FMDV challenge. However, the result obtained from animals that were injected with protein 3D together with plasmid pcDNA3.1/P12X3C was not satisfied. In conclusion, the results encouraged further work towards the development of a DNA vaccine against FMDV and provided the basis of research for DNA vaccine.

Gene gun-mediate DNA vaccination against foot-and-mouth disease virus

Foot-and-mouth disease (FMD) is one of the most dangerous diseases of cloven-hoofed animals and is a constant threat in the Middle-East and other regions throughout the world despite intensive vaccination programs. In this work, we describe the ability of FMDV expression constructs to protect pigs from FMDV challenge when used as a vaccine. The construct consists of encephalomyocarditis virus (EMCV) internal ribosome entry site (IRES), the entire P1 and 2A together with 3CD sequences, all in the same reading frame. Another plasmid that was tested, carries the serotype O1 (G) VP1, Asia1 VP1 and O1 (G) 3C. Between each of the genes the 3C cleavage sequences were inserted. All constructs carried the cytomegalo virus (CMV) promoter. Using immunofluorescent and immunoblot techniques, we could show the expression and processing of viral proteins. Following the application of FMDV expression constructs into pigs skin by ‘Gene Gun’, pigs were partially protected from FMDV challenge.

Development of Replication-Defective Adenovirus Serotype 5 Containing the Capsid and 3C Protease Coding Regions of Foot-and-Mouth Disease Virus as a Vaccine Candidate

A recombinant replication-defective human adenovirus serotype 5 vector containing FMDV capsid, P1-2A, and viral 3C protease coding regions was constructed. Two viral clones were isolated, Ad5-P12X3CWT, containing the wild-type (WT) 3C protease that processes capsid polyprotein precursor into mature capsid proteins, and Ad5-P12X3CMUT, containing a point mutation in the protease coding region that inhibits processing. In 293 cells infected with either virus, synthesis of the FMDV capsid polyprotein precursor occurred, but processing of the polyprotein into structural proteins VP0, VP3, and VP1 occurred only in 3CWT virus-infected cells. Immunoprecipitation with monospecific and monoclonal antibodies indicates possible higher order structure formation in Ad5-P12X3CWT virus-infected cells. The viruses were used to elicit immune responses in mice inoculated intramuscularly (im). Only virus containing the 3CWT elicited a neutralizing antibody response. After boosting, this neutralizing antibody response increased. Swine inoculated im with Ad5-P12X3CWT virus developed a neutralizing antibody response and were either completely or partially protected from contact challenge with an animal directly inoculated with virulent FMDV. This adenovirus vector may be an efficient system for the delivery of FMDV cDNA into animals, leading to a high level of neutralizing antibody production and protection from FMDV challenge.

Application of monoclonal antibodies to quality control of foot-and-mouth disease vaccines

Panels of monoclonal antibodies (mAbs) produced against foot-and-mouth disease (FMD) virus types O, A and C were selected for cell culture neutralization titre (NT), mouse protection index (MPI), trypsin sensitivity (TS) and avidity to different epitopes. The selected sets were used to assay the antigen concentration and the fit between FMDV vaccine and challenge strains. It was observed that FMD vaccines protect more than 75% of vaccinated cattle when manufactured with antigens characterized by (1) a high degree of fit with the potency control virus, and (2) mean ELISA 50% titres ( T 50) > 28 for O, > 18 for A and > 75 for C types, respectively, using the corresponding mAb set.