Filterite Filters Research Articles

Improved method for recovery of bacteriophage from large volumes of water using negatively charged microporous filters.

Current virus-recovery procedures using negatively charged microporous filters provide an inexpensive, reliable method for the recovery and detection of enteroviruses from water and wastewater; however, adjustment of the test samples to pH 3.5 to promote enterovirus adsorption results in significant inactivation of bacteriophage and an inability to simultaneously recover them from large volumes of water using this procedure. Procedures specifically designed for the detection of bacteriophage are currently in use but generally are only effective for small volumes of water. Positively charged filters can be used to recover both enteroviruses and bacteriophage from large volumes of water at neutral pH; however, the filters are expensive. The addition of manganese chloride to test solutions at pH 3.5 prior to filtration through negatively charged Filterite filters allowed for sampling of larger volumes of water by reducing the inactivation of bacteriophage and increasing the recovery of PRD1, MS2, and naturally isolated bacteriophage by a factor of four or five when compared with recoveries from solutions without MnCl2. This method provides an inexpensive, reliable alternative to large-volume bacteriophage recovery procedures that use positively charged filters at neutral pH.

IMPROVED METHOD FOR CONCENTRATION OF GIARDIA, CRYPTOSPORIDIUM, AND POLIOVIRUS FROM WATER

ABSTRACT Methods for the concentration of enteric viruses and the protozoan parasites, Giardia and Cryptosporidium, from drinking water currently require the use of two different types of filters. Electropositive or electronegative microporous filters (0.2–0.45 µm nominal porosity) are used for the collection of enteroviruses, while polypropylene spun-fiber filters (1 µm porosity) and small pleated cartridge filters are used for the collection of protozoan parasites from water. Since the filter mechanically traps the protozoa by size exclusion, a microporous filter with an appropriately small nominal porosity could possibly be used for co-collection of both protozoa and enteroviruses. This study compared the concentration efficiencies of a polypropylene fiber cartridge (DPPPY) filter and two different microporous filters (Filterite and 1MDS) with poliovirus (type 1), with respect to their ability to concentrate Giardia and Cryptosporidium from water. Giardia cysts and Cryptosporidium oocysts were added to 400 l of either tap water or tertiary treated wastewater and passed through the test filter. The protozoa were eluted from the polypropylene filter by hand-washing in a detergent solution. Viruses and protozoa were eluted from the microporous filter by two consecutive back-washes with a 1.5% beef extract, 0.1% Tween 80 solution. The eluent was then centrifuged to remove the parasites and the supernatant assayed for viruses. The overall efficiency was greater for the Filterite filter (40.4% for Giardia; 36.6% for Cryptosporidium) when compared to the spun fiber filter (10.1% for Giardia; 16.0% for Cryptosporidium). The Filterite filters were easier and faster to process than the polypropylene spun fiber filters. There was no significant difference in the recovery of protozoa from 1MDS and DPPPY filters. Co-collection of viruses and protozoan parasites from water onto the same filter is possible and can reduce the time and cost of routine water monitoring.

Removal of Viruses from Tapwater by Fiberglass Filters Modified with a Combination of Cationic Polymers

This paper describes the development of an inexpensive electropositive filter capable of adsorbing enteroviruses from waters at pH 5 to 9. We have previously reported that electronegative microporous filters composed of epoxy-fiberglass (Filterite) treated with the cationic polymers polyethylenimine (PEI) and Nalco 7111 cationic polymer (Nalco) were found to adsorb a greater percentage of enteroviruses and indigenous bacteriophages from water than untreated filters (Preston etal. 1988). However, no single polymer treated filter was capable of adsorbing poliovirus type 1 from buffer pH 5, 7, and 9. When PEI and Nalco 7111 cationic polymer treated filters were combined as a series of different filters or on the same filter, Poliovirus-1 was subsequently removed from buffer at pH 5, 7, and 9. Filterite filters modified with a combination of PEI and Nalco polymers were found to adsorb echovirus type 1, echovirus type 5, coxsackievirus type B5, and poliovirus type 1 from tap water at least as well as Virasorb 1-MDS microporous filters.

Method for detecting viruses in aerosols.

A simple method with poliovirus as the model was developed for recovering human enteric viruses from aerosols. Filterite filters (pore size, 0.45 micron; Filterite Corp., Timonium, Md.) moistened with glycine buffer (pH 3.5) were used for adsorbing the aerosolized virus. No virus passed the filter, even with air flow rates of 100 liters/min. Virus recovery from the filter was achieved by rapid elution with 800 ml of glycine buffer, pH 10. The virus in the primary eluate was reconcentrated by adjusting the pH to 3.5, adding AlCl3 to 0.0005 M, collecting the virus on a 0.25-micron-pore Filerite disk (diameter, 25 mm) and and eluting with 6 ml of buffer, pH 10. With this method, virus could be detected regularly in aerosols produced by flushing when 3 X 10(8) PFU of poliovirus were present in the toilet bowl. Poliovirus-containing fecal material from two of four infants who had recently received oral polio vaccine also yielded virus in the aerosols when feces containing 2.4 X 10(7) to 4.5 X 10(7) PFU of virus had been added to the toilet bowl. Persons infected with a variety of natural enteric viruses are known to excrete this amount of virus in their daily stools.

Effects of Water Quality on Microporous Filter Methods for Enteric Virus Concentration

Model enteric viruses were concentrated from seeded samples of raw, finished and granular activated carbon (GAC)-treated waters and from GAC-treated waters supplemented with humic or fulvic acid or bentonite clay particles by adsorption to electropositive (Virosorb 1MDS) filters at pH 7.5 or electronegative (Filterite) filters at pH 3.5 with and without 5 mM added MgCl2, followed by elution with 0.3% beef extract in 50 mM glycine at pH 9.5. Natural particulates in raw and finished waters had little effect on virus concentration efficiencies. Soluble organic compounds reduced virus adsorption efficiencies from both raw and finished waters compared to GAC-treated water, but the extent of interference varied with virus type and adsorption conditions. Humic and fulvic acids caused appreciable reductions in poliovirus adsorption and recovery efficiencies with both types of filters. Fulvic acid caused greater reductions in virus recovery with Virosorb 1MDS filters than with Filterite filters. Fulvic acid interference with virus recovery by Filterite filters was overcome by the presence of 5 mM MgCl2. Although humic acid reduced virus recoveries by both types of filters, its greatest effect was on virus elution and recovery from Filterite filters. Bentonite clay enhanced poliovirus retention by both filter types as much as 8-fold. However, the presence of clay often interfered with elution of retained viruses from both filter types. Under some conditions, overall virus recoveries were considerably lower from water with clay than from clay-free control water. The results of this study suggest that high concentrations of soluble organic matter such as humic and fulvic acids and suspended solids such as bentonite clay may interfere somewhat with virus recovery by filter adsorption-elution methods.

Effects of humic and fulvic acids on poliovirus concentration from water by microporous filtration.

Because naturally occurring organic matter is thought to interfere with virus adsorption to microporous filters, humic and fulvic acids isolated from a highly colored, soft surface water were used as model organics in studies on poliovirus adsorption to and recovery from electropositive Virosorb 1MDS and electronegative Filterite filters. Solutions of activated carbon-treated tap water containing 3, 10, and 30-mg/liter concentrations of humic or fulvic acid were seeded with known amounts of poliovirus and processed with Virosorb 1MDS filters at pH 7.5 or Filterite filters at pH 3.5 (with and without 5 mM MgCl2). Organic acids caused appreciable reductions in virus adsorption and recovery efficiencies with both types of filter. Fulvic acid caused greater reductions in poliovirus recovery with Virosorb 1MDS filters than with Filterite filters. Fulvic acid interference with poliovirus recovery by Filterite filters was overcome by the presence of 5 mM MgCl2. Although humic acid reduced poliovirus recoveries by both types of filter, its greatest effect was on virus elution and recovery from Filterite filters. Single-particle analyses demonstrated MgCl2 enhancement of poliovirus association with both organic acids at pH 3.5. The mechanisms by which each organic acid reduced virus adsorption and recovery appeared to be different for each type of filter.

Round robin investigation of methods for the recovery of poliovirus from drinking water.

Six laboratories actively involved in water virology research participated in a methods evaluation study, conducted under the auspices of the American Society for Testing and Materials Committee on Viruses in the Aquatic Environment, Task Force on Drinking Water. Each participant was asked to examine the Viradel (virus adsorption-elution) method with cartridge-type Filterite filters for virus adsorption and organic flocculation and aluminum hydroxide-hydroextraction for reconcentration. Virus was adsorbed to filter media at pH 3.5 and eluted with either glycine buffer (pH 10.5) or beef extract-glycine (pHG 9.0). Considerable variation was noted in the quantity of virus recovered from four 100-liter samples of dechlorinated tapwater seeded with low (350 to 860 PFU) and high (1,837 to 4,689 PFU) doses of poliovirus type 1. To have a more uniform standard of comparison, all the test samples were reassayed in one laboratory, where titers were also determined for the virus seed. Test results of the Viradel-organic flocculation method indicated that the average percentage of virus recovery for low-input experiments was 66%, with a range of 8 to 20% in two laboratories, 49 to 63% in three laboratories, and 198% in one laboratory. For the high-input experiments, two laboratories reported recoveries of 6 to 12%, and four laboratories reported recoveries of 26 to 46%. For the Viradel aluminum hydroxide-hydroextraction procedure, two laboratories recovered 9 to 11%, whereas four obtained 17 to 34% for low-input experiments. For the high-input tests, two laboratories reported a recovery of 3 to 5%, and four recovered 11 to 18% of the seeded virus.(ABSTRACT TRUNCATED AT 250 WORDS)

Development of a method for detection of human rotavirus in water and sewage.

The simian rotavirus SA11 was used to develop a simple, reliable, and efficient method to concentrate rotavirus from tap water, treated sewage, and raw sewage by absorption to and elution from Filterite fiberglass-epoxy filters. SA11 adsorbed optimally to Filterite filters from water containing 0.5 mM AlCl3 at pH 3.5. Filter-bound virus was eluted with 0.05 M glycine-NaOH supplemented with 10% tryptose phosphate broth at pH 10. SA11 was quantitated by plaque assay, whereas human rotavirus was detected by immunofluorescence. The method was applied to detect rotavirus in raw and treated sewage at two Houston, Tex., sewage treatment plants. The sewage isolates were identified as rotavirus, probably a human strain, based on several criteria. The sewage isolates were detectable by an immunofluorescence test, using anti-SA11 serum which would detect the simian, human bovine, and porcine rotaviruses. No reaction was noted by immunofluorescence with the reoviruses or several common enteroviruses. The sewage isolates were neutralized by convalescent sera from a human adult and infant who had been infected by rotavirus as well as by a hyperimmune serum prepared in guinea pigs against purified human rotavirus. Preimmune or preillness sera did not react with the isolates by neutralization or immunofluorescence. The natural isolates were sensitive to pH 11 and other inactivating agents, similar to SA11. The buoyant density of the sewage isolates in CsCl gradients was 1.36 g/cm3, which is the value usually reported for complete, infectious rotavirus particles. The double-shelled particle diameter was 67.1 +/- 2.4 nm. Finally, electron micrographs of cell lysates inoculated with the sewage isolate showed particles displaying characteristic rotavirus morphology.