Efficacy Of Neutral Electrolyzed Water Research Articles

Effect of Storage Conditions on Shelf Stability of Undiluted Neutral Electrolyzed Water

Neutral electrolyzed water (NEW) is an oxidizing sanitizer that can be made locally on-site; it is often stored in a ready-to-use format to accumulate the large volumes required for periodic or seasonal use. The shelf stability of NEW sanitizer was, therefore, assessed under various storage conditions to guide the development of protocols for its industrial application. To that end, fresh NEW with an available chlorine concentration (ACC) of 480 mg/L, pH 6.96, and oxidation reduction potential (ORP) of 916 mV was stored under different conditions. These were open or sealed polypropylene bottles, three different surface area-to-volume (SA:V) ratios (0.9, 1.7, and 8.7), and two temperatures (4 and 25°C). NEW stored at 4°C was significantly more stable than NEW stored at 25°C; ACC and pH decreased by 137 mg/L and 0.7, respectively, whereas ORP increased by 23 mV, after 101 days of storage. At 25°C, ACC decreased to <0.01 mg/L after 52 days in bottles with a SA:V ratio of 8.7, with a similar decrease after 101 days in bottles with a SA:V ratio of 1.7. However, pH decreased by up to 3.7 pH units, and ORP increased by up to 208 mV. The antimicrobial efficacy of "aged" electrolyzed oxidizing (EO) water with different ACC and ORP, but the same pH (i.e., 3.4 ± 0.2), was evaluated against Escherichia coli and Listeria innocua to determine any differences in residual antimicrobial activity. EO water with an ACC of ≥7 mg/L and an ORP of 1,094 mV caused a reduction of at least 4.7 log, whereas EO water with nondetectable ACC and considerably high ORP (716 mV) had little antimicrobial effect (<1-log reduction). Results from this study indicate that the efficacy of NEW as a sanitizer for large-scale applications such as horticulture can be maintained for at least 3 months when it is stored in closed containers with low SA:V ratio at low temperatures.

Evaluation of the antimicrobial efficacy of neutral electrolyzed water on pork products and the formation of viable but nonculturable (VBNC) pathogens

The goals of this study were to evaluate the antimicrobial efficacy of Neutral electrolyzed oxidizing (NEO) water on E. coli O157:H7, Salmonella Enteritidis and Yersinia enterocolitica in both pure culture and on inoculated pork chops and skin samples, and to investigate the formation of viable but nonculturable (VBNC) pathogens after treatments. Both the plate count method and flow cytometry were used to evaluate antimicrobial efficacy on pure cultures. Different concentrations of NEO water were prepared by diluting the original NEO water (100%) with sterilized deionized water. The antimicrobial efficacy increased as the concentrations of NEO water increased. The flow cytometry results showed that treating with diluted NEO water led to the formation of VBNC cells. No VBNC cells formed when treating pure cultures with 50% or 100% NEO water. Yersinia cultures were found to be more resistant to NEO treatments than Salmonella and E. coli O157:H7 cultures, with Yersinia cultures showing lower reductions and higher levels of VBNC cells after treatments. The antimicrobial efficacy of NEO water was significantly better on skin samples than on pork chops. The differences in protein content and structure between pork chops and skin samples serve as major factors impacting the NEO water's efficacy.

Efficacy of Neutral Electrolyzed Water for Inactivation of Human Norovirus.

Human norovirus (NoV) is the leading cause of acute gastroenteritis worldwide. Persistence on surfaces and resistance to many conventional disinfectants contribute to widespread transmission of norovirus. We examined the efficacy of neutral electrolyzed water (NEW; pH 7) for inactivation of human NoV GII.4 Sydney in suspension (ASTM method 1052-11) and on stainless steel surfaces (ASTM method 1053-11) with and without an additional soil load. The impact of the disinfectant on viral capsid was assessed using reverse transcriptase quantitative PCR (RT-qPCR; with an RNase pretreatment), SDS-PAGE, transmission electron microscopy, and a histo-blood group antigen (HBGA) receptor-binding assay. These studies were done in parallel with those using Tulane virus (TuV), a cultivable human NoV surrogate. Neutral electrolyzed water at 250 ppm free available chlorine produced a 4.8- and 0.4-log10 reduction in NoV genome copy number after 1 min in suspension and on stainless steel, respectively. Increasing the contact time on surfaces to 5, 10, 15, and 30 min reduced human NoV genomic copies by 0.5, 1.6, 2.4, and 5.0 log10 and TuV infectious titers by 2.4, 3.0, 3.8, and 4.1 log10 PFU, respectively. Increased soil load effectively eliminated antiviral efficacy regardless of testing method and virus. Exposure to NEW induced a near complete loss of receptor binding (5 ppm, 30 s), degradation of VP1 major capsid protein (250 ppm, 5 min), and increased virus particle aggregation (150 ppm, 30 min). Neutral electrolyzed water at 250 ppm shows promise as an antinoroviral disinfectant when used on precleaned stainless steel surfaces.IMPORTANCE Norovirus is the leading cause of acute viral gastroenteritis worldwide. Transmission occurs by fecal-oral or vomitus-oral routes. The persistence of norovirus on contaminated environmental surfaces exacerbates its spread, as does its resistance to many conventional disinfectants. The purpose of this research was to evaluate the antinoroviral efficacy of neutral electrolyzed water (NEW), a novel chlorine-based disinfectant that can be used at reduced concentrations, making it more environmentally friendly and less corrosive than bleach. An industrial-scale electrochemical activation device capable of producing relatively stable electrolyzed water at a wide pH range was used in this study. Experiments showed that 250 ppm NEW effectively eliminated (defined as a 5-log10 reduction) human norovirus GII.4 Sydney (epidemic strain) on clean stainless steel surfaces after a 30-min exposure. Supporting studies showed that, like bleach, NEW causes inactivation by disrupting the virus capsid. This product shows promise as a bleach alternative with antinoroviral efficacy.

The effects of organic compounds on inactivation efficacy of Artemia salina by neutral electrolyzed water

The introduction of aquatic non-indigenous organisms and pathogens via ships ballast water is considered as a great treat to global marine ecosystems, costal economy and public health. This issue can be efficiently addressed by electrolytic treatment technology. In this work, the effects of organic compounds on inactivation efficacy of neutral electrolyzed water were studied by bench scale test and land-based test with Artemia salina as an indicator organism. In bench scale test, both glucose and chitosan significantly accelerated TRO decay of neutral electrolyzed water, while the other kinds of dissolved organic compounds (sodium citrate and sucrose) and particle organic compounds (corn starch) had no significant effect on TRO decay. Both glucose and chitosan weakened the inactivation efficacy of neutral electrolyzed water, especially at 24h. The results of land-based test also indicated that the inactivation efficacy of ballast water management system not only depended on TRO initial concentration, but also on the property of organic compounds. The presence of glucose and chitosan indicated the need of high level of initial TRO concentration to reach good inactivation efficacy. The results of this study may be useful to decide the initial TRO concentration in ballast water treatment with electrolysis technology.

Efficacy of Neutral Electrolyzed Water for Reducing Pathogenic Bacteria Contaminating Shrimp

Pathogenic contamination is a food safety concern. This study was conducted to investigate the efficacy of neutral electrolyzed water (NEW) in killing pathogens, namely, Vibrio parahaemolyticus, Vibrio vulnificus, Salmonella Enteritidis, and Escherichia coli in shrimp. Pure cultures of each pathogen were submerged separately in NEW containing five different chlorine concentrations: 10, 30, 50, 70, and 100 ppm. For each concentration, three submersion times were tested: 1, 3, and 5 min. The population of V. parahaemolyticus was rapidly reduced even at low concentrations, but prolonged contact times caused only a slight reduction. V. vulnificus was gradually inhibited with increasing NEW concentrations and contact times. For the V. parahaemolyticus applications of 70 ppm for 5 min and of 100 ppm for 3 min, each eliminated 7 log CFU/ml. For V. vulnificus, applications of 50 ppm for 3 min and 100 ppm for 1 min, each eliminated 7 log CFU/ml. Salmonella Enteritidis and E. coli were slightly reduced by NEW. Applications of 50 ppm for 15 min and 10 ppm for 30 min completely eliminated 4.16 log CFU/g of V. parahaemolyticus in inoculated shrimp, while only a 1-log CFU/g reduction of V. vulnificus was detected. Soaking shrimp in 10 ppm NEW for 30 min did not affect its sensory quality. Our results suggest NEW could be an alternative sanitizer to improve the microbiological quality of seafood.

Decontamination efficacy of neutral electrolyzed water to eliminate indigenous flora on a large-scale of cabbage and carrot both in the laboratory and on a real processing line

The decontamination efficacy of neutral electrolyzed water (NEW) was evaluated using shredded cabbages and carrots in both a scalable laboratory system (experiment I) and an actual processing line in a plant (experiment II). In experiment I, the antimicrobial effect of highly concentrated NEW (up to the maximum regulated level: 200ppm) was tested to determine the appropriate conditions for use in an actual plant test: (1) hypochlorous acid (HClO) concentration (100, 150, and 200ppm), (2) ratio of sample weight to NEW volume (1:5, 1:10, and 1:20), and (3) treatment time (5, 10, 20, and 30min), using 2kg of shredded cabbages and carrots. In experiment II, the feasibility of the NEW treatment was validated on an actual processing line (treatment unit: 20kg), including cutting, three washing steps (two air bubble washes for 5min each and 150ppm NEW for 5min at ratio of 1:10), rinsing (5min), and dehydration (5min). Overall, the microbial reductions tended to increase as the HClO concentration, ratio of sample to NEW, and treatment time increased. The results obtained from experiment I indicated that the maximum conditions (NEW 200ppm, 1:20, 30min) achieved 3.3–3.5 log CFU/g reductions in the coliform counts. After treatment with 200ppm NEW for >10min, however, there were noticeable color changes (color differences, DE>5.0) in both the shredded cabbages and carrots. In the experiment II, the microbial populations were not affected by cutting and two air bubble treatments, whereas washing with NEW greatly reduced both the aerobic plate counts (1.93–2.17 log CFU/g) and coliform counts (0.97–1.51 log CFU/g). More than 2 log CFU/g of indigenous flora were reduced from raw materials to final products with both shredded cabbages (2.05–2.48 log CFU/g) and carrots (2.34–2.76 log CFU/g). These results may provide useful recommendations for the practical application of highly concentrated NEW in the fresh-cut produce industry to improve the microbiological safety without quality deterioration.

Efficacy of neutral electrolyzed water for sanitization of cutting boards used in the preparation of foods

The effectiveness of neutral electrolyzed water (NEW) to sanitize cutting boards used for food preparation was investigated. Cutting boards made of hardwood and bamboo were inoculated with Escherichia coli K12 and Listeria innocua, dried for 1h, washed, rinsed and sanitized with NEW, sodium hypochlorite (NaClO) solution, or tap water (control). After each washing protocol, surviving bacterial populations were determined. Results showed that both NEW and NaClO sanitizing solutions produced similar levels of bacterial reductions. In manual washing, the population reductions by NEW and NaClO were 3.4 and 3.6log10CFU/100cm2 for E. coli, and 4.1 and 3.9log10CFU/100cm2 for L. innocua, respectively. In the automatic washing, the reductions by NEW and NaClO were 4.0 and 4.0log10CFU/100cm2 for E. coli, and 4.2 and 3.6log10CFU/100cm2 for L. innocua, respectively. No significant differences (P>0.05) were observed in surviving bacteria counts when comparing board material types.

Efficacy of neutral electrolyzed water (NEW) for reducing microbial contamination on minimally-processed vegetables

Consumption of minimally-processed, or fresh-cut, fruit and vegetables has rapidly increased in recent years, but there have also been several reported outbreaks associated with the consumption of these products. Sodium hypochlorite is currently the most widespread disinfectant used by fresh-cut industries. Neutral electrolyzed water (NEW) is a novel disinfection system that could represent an alternative to sodium hypochlorite. The aim of the study was to determine whether NEW could replace sodium hypochlorite in the fresh-cut produce industry. The effects of NEW, applied in different concentrations, at different treatment temperatures and for different times, in the reduction of the foodborne pathogens Salmonella, Listeria monocytogenes and Escherichia coli O157:H7 and against the spoilage bacterium Erwinia carotovora were tested in lettuce. Lettuce was artificially inoculated by dipping it in a suspension of the studied pathogens at 10 8, 10 7 or 10 5 cfu ml −1, depending on the assay. The NEW treatment was always compared with washing with deionized water and with a standard hypochlorite treatment. The effect of inoculum size was also studied. Finally, the effect of NEW on the indigenous microbiota of different packaged fresh-cut products was also determined. The bactericidal activity of diluted NEW (containing approximately 50 ppm of free chlorine, pH 8.60) against E. coli O157:H7, Salmonella, L. innocua and E. carotovora on lettuce was similar to that of chlorinated water (120 ppm of free chlorine) with reductions of 1–2 log units. There were generally no significant differences when treating lettuce with NEW for 1 and 3 min. Neither inoculation dose (10 7 or 10 5 cfu ml −1) influenced the bacterial reduction achieved. Treating fresh-cut lettuce, carrot, endive, corn salad and ‘Four seasons’ salad with NEW 1:5 (containing about 50 ppm of free chlorine) was equally effective as applying chlorinated water at 120 ppm. Microbial reduction depended on the vegetable tested: NEW and sodium hypochlorite treatments were more effective on carrot and endive than on iceberg lettuce, ‘Four seasons’ salad and corn salad. The reductions of indigenous microbiota were smaller than those obtained with the artificially inoculated bacteria tested (0.5–1.2 log reduction). NEW seems to be a promising disinfection method as it would allow to reduce the amount of free chlorine used for the disinfection of fresh-cut produce by the food industry, as the same microbial reduction as sodium hypochlorite is obtained. This would constitute a safer, ‘in situ’, and easier to handle way of ensuring food safety.

Efficacy of Neutral Electrolyzed Water To Inactivate Escherichia coli, Listeria monocytogenes, Pseudomonas aeruginosa, and Staphylococcus aureus on Plastic and Wooden Kitchen Cutting Boards

This study evaluated the efficacy of neutral electrolyzed water (NEW; 64.1 mg/liter of active chlorine) to reduce populations of Escherichia coli, Pseudomonas aeruginosa, Staphylococcus aureus, and Listeria monocytogenes on plastic and wooden kitchen cutting boards. Its effectiveness was compared with that of a sodium hypochlorite solution (NaClO; 62.3 mg/liter of active chlorine). Inoculated portions of cutting boards were rinsed in either NEW or NaClO solutions, or deionized water (control). Plastic boards were rinsed for 1 min and wooden boards for 1 and 5 min. After each treatment, the surviving population of each strain was determined on the surface and in the soaking water. No significant difference (P ≥ 0.05) was found between the final populations of each strain with regard to the treatment solutions (NEW or NaClO). However, a significant difference (P ≤ 0.05) was revealed between surface materials after 1 min of washing. Whereas in plastic boards the initial bacterial populations were reduced by 5 log CFU/50 cm2, in wooden cutting boards they underwent a reduction of <3 log CFU/50 cm2. A 5-min exposure time yielded reductions of about 4 log CFU/50 cm2. The surviving populations of all bacteria in NEW and NaClO washing solutions were <1 log CFU/ml after soaking both surfaces. This study revealed that NEW treatment is an effective method for reducing microbial contamination on plastic and wooden cutting boards. NEW efficacy was comparable to that of NaClO, with the advantage of having a larger storage time.

Inactivation of Escherichia coli O157:H7, Salmonella enteritidis and Listeria monocytogenes on the surface of tomatoes by neutral electrolyzed water.

To determine the efficacy of neutral electrolyzed water (NEW) in killing Escherichia coli O157:H7, Salmonella enteritidis and Listeria monocytogenes, as well as nonpathogenic E. coli, on the surface of tomatoes, and to evaluate the effect of rinsing with NEW on the organoleptic characteristics of the tomatoes. The bactericidal activity of NEW, containing 444 or 89 mg l(-1) of active chlorine, was evaluated over pure cultures (8.5 log CFU ml(-1)) of the above-mentioned strains. All of them were reduced by more than 6 log CFU ml(-1) within 5 min of exposure to NEW. Fresh tomatoes were surface-inoculated with the same strains, and rinsed in NEW (89 mg l(-1) of active chlorine) or in deionized sterile water (control), for 30 or 60 s. In the NEW treatments, independent of the strain and of the treatment time, an initial surface population of about 5 log CFU sq.cm(-1) was reduced to <1 log CFU sq.cm(-1), and no cells were detected in the washing solution by plating procedure. A sensory evaluation was conducted to ascertain possible alterations in organoleptic qualities, yielding no significant differences with regard to untreated tomatoes. Rinsing in NEW reveals as an effective method to control the presence of E. coli O157:H7, S. enteritidis and L. monocytogenes on the surface of fresh tomatoes, without affecting their organoleptic characteristics. This indicates its potential application for the decontamination of fresh produce surfaces.