Effects Of Dried Distillers Grains With Solubles Research Articles

PENGARUH PENGGUNAAN CORN DRIED DISTILLERS GRAINS WITH SOLUBLES DALAM RANSUM TERHADAP PERFORMAN PUYUH JANTAN

Feeding trial were conducted to study the effect of the use of corn dried distillers grains with solubles (DDGS) in the diets on growth performance of male coturnix. One hundred and twenty male coturnixs were allotted into four dietary treatments containing 0, 10, 20 and 30% DDGS respectively in a Completely Randomized Design. Each treatment was replicated eight times. Feed and water were provided ad libitum. The variables observed were feed intake, average daily gain and feed conversion ratio. The data were analyzed using 0ne Way of analyses of variance (ANOVA). The result indicated that there was no effect of DDGS on the feed intake, average daily gain and feed conversion ratio. It could be concluded that DDGS can be used up to 30% in the diets of male coturnix. Keywords: Growth performance, Corn-DDGS, Male coturnix)

Effects of dietary L-carnitine and dried distillers grains with solubles on growth, carcass characteristics, and loin and fat quality of growing-finishing pigs1,2

A total of 1104 barrows and gilts (PIC 337 × 1050, Pig Improvement Company, Hendersonville, TN), weighing 36 ± 1 kg were used in a 109-d study to evaluate effects of dietary L-carnitine and dried distillers grains with solubles (DDGS) on growth, carcass traits, and loin and fat quality. Pigs were blocked by BW and randomly assigned to 1 of 6 treatments, with 7 pens per treatment. Treatments were arranged as a 2 × 3 factorial, with main effects of DDGS (30% in Phases 1, 2, and 3, and 20% in Phase 4) and L-carnitine (0, 50, or 100 mg/kg). Overall (d 0 to 109), dietary L-carnitine tended to improve ADG (linear, P = 0.07). Pigs fed 50 mg/kg L-carnitine but no DDGS had greater G:F than pigs fed 0 or 100 mg/kg, whereas when diets containing DDGS were fed, 50 mg/kg of L-carnitine reduced G:F compared with pigs fed 0 or 100 mg/kg (quadratic DDGS × L-carnitine, P < 0.01). There was no effect of DDGS × L-carnitine for any carcass traits, but pigs fed increasing dietary inclusion levels of L-carnitine produced heavier HCW (quadratic, P = 0.03), greater carcass yields (quadratic, P = 0.07), and greater fat depths (quadratic, P = 0.04), with the greatest response observed in pigs fed 50 mg/kg dietary L-carnitine. Feeding L-carnitine increased purge loss (linear, P = 0.03), whereas feeding DDGS tended to decrease (P = 0.06) LM marbling scores. The LM from pigs fed 50 mg/kg L-carnitine and DDGS had lower shear force values compared with LM chops from pigs fed either 0 or 100 mg/kg; however, shear force values were similar across dietary L-carnitine levels in diets devoid of DDGS (quadratic DDGS × L-carnitine, P < 0.01). Furthermore, increasing L-carnitine in DDGS diets increased fresh LM color scores, but pigs fed DDGS-free diets produced LM chops with similar subjective color scores (linear DDGS × L-carnitine, P = 0.03). As expected, feeding DDGS increased (P < 0.001) iodine value (IV) in jowl fat samples, but dietary L-carnitine did not alter IV. The concentrations of C18:2n-6 and C20:2 were decreased with increasing L-carnitine in DDGS-containing diets, but not in diets without DDGS (linear DDGS × L-carnitine, P ≤ 0.04). Results of this study indicate that dietary DDGS did not affect growth, but led to more unsaturation of jowl fat, whereas feeding 50 mg/kg of L-carnitine improved HCW and reduced C18:2n-6 in jowl fat when fed in combination with DDGS.

Effects of distillers’ dried grains with solubles from corn, wheat or a 50:50 corn:wheat blend on performance, carcass characteristics and serum sulphate levels of feedlot steers

Amat, S., Hendrick, S., McAllister, T. A., Block, H. C. and McKinnon, J. J. 2012. Effects of distillers’ dried grains with solubles from corn, wheat or a 50:50 corn:wheat blend on performance, carcass characteristics and serum sulphate levels of feedlot steers. Can. J. Anim. Sci. 92: 343–351. Two trials were conducted to evaluate the effects of corn (CDDGS), wheat (WDDGS) or a 50:50 corn:wheat blend (BDDGS) dried distillers’ grains with solubles (DDGS) on performance (Trials 1 and 2), carcass traits (Trial 2) and serum sulphate level (Trial 2) of steers. In Trial 1, 396 steers (281.1±19.6 kg) were fed one of three backgrounding diets. The control diet was 34.3% barley grain, 26.0% grass hay, 10.3% barley straw, 22.8% barley silage and 6.7% supplement [dry matter (DM) basis]. For the two treatments, 17% of the barley was replaced with CDDGS or WDDGS. In Trial 2, 288 steers (273.9±18.5 kg) were backgrounded and finished. Backgrounding diets were identical to Trial 1, with a third treatment where 17% of the barley grain was replaced with BDDGS. The control finishing diet was 86.8% barley grain, 7.4% barley silage and 5.8% supplement (DM basis). Treatments included replacement of 40% of the barley grain (DM basis) with CDDGS, BDDGS or WDDGS. In Trial 1, there was no effect of DDGS on dry matter intake (DMI) (P=0.49), average daily gain (ADG) (P=0.64), feed efficiency (P=0.06), ultrasound fat (USFAT) (P=0.90) or longissimus dorsi (USLD) (P=0.071) area. In Trial 2, overall, DMI of cattle fed WDDGS was higher (P=0.03) than control or CDDGS cattle, with BDDGS intermediate. In contrast, ADG was higher (P&lt;0.01) for the CDDGS and BDDGS than either the control or WDDGS fed cattle. The CDDGS and BDDGS cattle were more efficient (P&lt;0.01) than those fed WDDGS with the controls intermediate. Cattle fed CDDGS or WDDGS exhibited higher (P&lt;0.01) serum sulphate levels compared with BDDGS or control cattle, reflecting differences in sulphur intake. The results indicate that CDDGS is a superior energy source to WDDGS and that both sources of DDGS can be used as a partial replacement for barley in backgrounding and finishing diets for cattle.

Effects of increasing crude glycerol and dried distillers grains with solubles on growth performance, carcass characteristics, and carcass fat quality of finishing pigs1,2

This study was conducted to determine the effects of dietary crude glycerol and dried distillers grains with solubles (DDGS) on growing-finishing pig performance, carcass characteristics, and carcass fat quality. We hypothesized that because dietary crude glycerol has been observed to increase carcass SFA, it might ameliorate the negative effects of DDGS on fat quality. The 97-d study was conducted at a commercial swine research facility in southwestern Minnesota with 1,160 barrows (initial BW = 31.0 ± 1.1 kg). Pigs were blocked by initial BW, and pens were randomly allotted to 1 of 6 dietary treatments with 7 replications per treatment. Treatments were arranged in a 2 × 3 factorial with main effects of crude glycerol (0, 2.5, or 5%) and DDGS (0 or 20%). All corn-soybean meal-based diets contained 3% added fat (choice white grease). There were no glycerol × DDGS interactions for any response criteria evaluated. Increasing dietary glycerol did not affect finishing pig growth performance. Adding 20% DDGS to the diet did not affect ADG; however, finishing pigs fed diets with added DDGS had greater (2.47 vs. 2.41 kg/d; P = 0.02) ADFI and poorer (0.39 vs. 0.40; P = 0.01) G:F than pigs not fed DDGS. Feeding increasing dietary glycerol or 20% DDGS did not affect carcass characteristics. For carcass fat quality, feeding 20% DDGS resulted in decreased (P < 0.01) palmitic and oleic acids, total SFA and total MUFA, and increased (P < 0.01) linoleic, total PUFA, total unsaturated fatty acids, and iodine value in jowl fat, belly fat, and backfat. Increasing dietary crude glycerol increased myristic acid (linear, P < 0.05) and MUFA (quadratic, P < 0.05) in jowl fat and increased (quadratic, P < 0.05) oleic acid and MUFA in backfat. In conclusion, feeding 20% DDGS to finishing pigs increased ADFI, reduced G:F, and increased carcass fat iodine value, whereas feeding crude glycerol did not influence growth performance, carcass characteristics, and had a minor influence on fatty acids of carcass fat. Both of these biofuel coproducts can be used in combination without affecting finishing pig performance or carcass traits; however, feeding crude glycerol did not fully mitigate the increased unsaturation of carcass fat observed when feeding DDGS.