Cross-shift Lung Function Research Articles

Reduced Cross-Shift Lung Function and Respiratory Symptoms among Integrated Textile Factory Workers in Ethiopia.

Chronic respiratory symptoms and reduction in lung function has been described as a common health problem among textile workers in low- and middle-income countries. The objective of this study was to measure lung function and respiratory symptoms among workers from an integrated textile factory. A comparative cross-sectional study design with a cross-shift lung function measurement was performed in 306 cotton dust exposed workers from an integrated textile factory and 156 control workers from a water bottling factory. An integrated textile factory typically has four main production departments (spinning, weaving, finishing, and garment) that process raw cotton and manufacture clothes or fabrics. Respiratory symptoms were assessed by adopting the standard American Thoracic Society questionnaire. Descriptive statistics and logistic and linear regression analysis were used. The prevalence of respiratory symptoms was significantly higher among textile workers (54%) than in controls (28%). Chronic cough, chest tightness, and breathlessness were significantly higher among textile workers (23%, 33%, and 37%, respectively) than in the control group (5%, 17% and 6%, respectively). Breathlessness was the most prevalent chronic respiratory symptom with highest adjusted odds ratio 9.4 (95% CI 4.4–20.3). A significantly higher cross-shift lung function reduction was observed among textile workers (123 mL for FEV1 and 129 mL for FVC) compared with the control group (14 mL for FEV1 and 12 mL for FVC). Thus, workers’ respiratory health protection programs should be strengthened in textile factories.

Lipopolysaccharides Endotoxin-containing Paddy Dust Leads to Cross-shift Lung Function Decline and Respiratory Complaints in Paddy Milling Machine Operators

.

Respiratory symptoms and cross-shift lung function in relation to cotton dust and endotoxin exposure in textile workers in Nepal: a cross-sectional study

ObjectivesInhalation of a cotton-based particulates has previously been associated with respiratory symptoms and impaired lung function. This study investigates the respiratory health of Nepalese textile workers in relation to dust...

Exposures and Cross-shift Lung Function Declines in Wildland Firefighters

Respiratory problems are common among wildland firefighters. However, there are few studies directly linking occupational exposures to respiratory effects in this population. Our objective was to characterize wildland fire fighting occupational exposures and assess their associations with cross-shift changes in lung function. We studied 17 members of the Alpine Interagency Hotshot Crew with environmental sampling and pulmonary function testing during a large wildfire. We characterized particles by examining size distribution and mass concentration, and conducting elemental and morphological analyses. We examined associations between cross-shift lung function change and various analytes, including levoglucosan, an indicator of wood smoke from burning biomass. The levoglucosan component of the wildfire aerosol showed a predominantly bimodal size distribution: a coarse particle mode with a mass median aerodynamic diameter about 12 μm and a fine particle mode with a mass median aerodynamic diameter < 0.5 μm. Levoglucosan was found mainly in the respirable fraction and its concentration was higher for fire line construction operations than for mop-up operations. Larger cross-shift declines in forced expiratory volume in one second were associated with exposure to higher concentrations of respirable levoglucosan (p < 0.05). Paired analyses of real-time personal air sampling measurements indicated that higher carbon monoxide (CO) concentrations were correlated with higher particulate concentrations when examined by mean values, but not by individual data points. However, low CO concentrations did not provide reliable assurance of concomitantly low particulate concentrations. We conclude that inhalation of fine smoke particles is associated with acute lung function decline in some wildland firefighters. Based on short-term findings, it appears important to address possible long-term respiratory health issues for wildland firefighters. [Supplementary materials are available for this article. Go to the publisher's online edition of Journal of Occupational and Environmental Hygiene for the following free supplemental resources: a file containing additional information on historical studies of wildland fire exposures, a file containing the daily-exposure-severity questionnaire completed by wildland firefighter participants at the end of each day, and a file containing additional details of the investigation of correlations between carbon monoxide concentrations and other measured exposure factors in the current study.]

Pulmonary function, respiratory symptoms, and dust exposures among workers engaged in early manufacturing processes of tea: a cohort study

BackgroundTo evaluate pulmonary function and respiratory symptoms in workers engaged in the early manufacturing processes of tea and to identify the associated factors, we conducted a study in a tea production area in Taiwan.MethodsWe recruited tea workers who engaged in the early manufacturing process in the Mountain Ali area in Taiwan and a comparison group of local office workers who were matched for age, gender, and smoking habits. We performed questionnaire interviews, pulmonary function tests, skin prick tests, and measurement of specific IgE for tea on the participants and assessed tea dust exposures in the tea factories.ResultsThe 91 participating tea workers had higher prevalence of respiratory symptoms than the comparison group (32 participants). Among tea workers, ball-rolling workers had the highest prevalence of symptoms and the highest exposures of inhalable dusts. At baseline, tea workers had similar pulmonary functions as the comparison group, but compared to the other tea workers ball-rolling workers had a lower ratio of the 1-second forced expiratory volume to forced vital capacity (FEV1/FVC) and a lower maximal mid-expiratory flow rate expressed as% of the predicted value--MMF (%pred). A total of 58 tea workers participated in the on-site investigation and the cross-shift lung function measurements. We found ball-rolling yielded the highest inhalable dust level, panning yielded the highest respirable dust level, and withering yielded the lowest levels of both dusts. Ball-rolling also yielded the highest coarse fraction (defined as inhalable dusts minus respirable dusts), which represented exposures from nose to tracheobronchial tract. During the shift, we observed significant declines in pulmonary function, especially in ball-rolling workers. Multiple regressions showed that age, height, work tasks, coarse fraction, and number of months working in tea manufacturing each year were independent predictors of certain pulmonary function parameters in tea workers.ConclusionsTea workers engaged in early manufacturing processes of tea have higher prevalence of respiratory symptoms and pulmonary function impairment, which might be related to tea dust exposures, especially the coarse fraction.

Are respiratory decrements associated with exposure to particles including endotoxins on large California dairies?

ObjectivesTo determine whether exposure to particulate matter (PM) including endotoxins on large California dairies is associated with decreased cross-shift respiratory function.MethodsMale workers at 13 dairies and one control facility wore...

Health effects of airborne exposures from concentrated animal feeding operations.

Toxic gases, vapors, and particles are emitted from concentrated animal feeding operations (CAFOs) into the general environment. These include ammonia, hydrogen sulfide, carbon dioxide, malodorous vapors, and particles contaminated with a wide range of microorganisms. Little is known about the health risks of exposure to these agents for people living in the surrounding areas. Malodor is one of the predominant concerns, and there is evidence that psychophysiologic changes may occur as a result of exposure to malodorous compounds. There is a paucity of data regarding community adverse health effects related to low-level gas and particulate emissions. Most information comes from studies among workers in CAFO installations. Research over the last decades has shown that microbial exposures, especially endotoxin exposure, are related to deleterious respiratory health effects, of which cross-shift lung function decline and accelerated decline over time are the most pronounced effects. Studies in naïve subjects and workers have shown respiratory inflammatory responses related to the microbial load. This working group, which was part of the Conference on Environmental Health Impacts of Concentrated Animal Feeding Operations: Anticipating Hazards—Searching for Solutions, concluded that there is a great need to evaluate health effects from exposures to the toxic gases, vapors, and particles emitted into the general environment by CAFOs. Research should focus not only on nuisance and odors but also on potential health effects from microbial exposures, concentrating on susceptible subgroups, especially asthmatic children and the elderly, since these exposures have been shown to be related to respiratory health effects among workers in CAFOs.

Exposure–response relationship between endotoxin exposure and lung function impairment in cotton textile workers

Preventive workplace regulations are so far not based on an ubiquitously accepted threshold for airborne endotoxin in the bioaerosol. In a cross-sectional study, 150 employees of a cotton spinning mill underwent lung function testing. Furthermore, in a random subset of 75 textile workers cross-shift lung function test and methacholine challenges were performed. Airborne current endotoxin exposure was classified as "low", "medium", and "high" (<or=100, >100-<or=450, and >450 Endotoxin Units (EU)/m(3), respectively) based on endotoxin activity. The exposure-response relationship between current endotoxin exposure and prevalence of an obstructive ventilation pattern was significant (test for linear trend: P = 0.019); the adjusted odds ratio for high endotoxin exposure was 11.22 (95% confidence interval 1.03-121.17). Within individuals, FEV(1)/FVC% was significantly reduced after the shift (paired t test: P = 0.009) but not related to current endotoxin exposure. Twelve workers showed bronchial hyperresponsiveness (8.1% before and 12.2% after the work shift; Fisher's exact test: P = 0.021). The study among German cotton textile workers suggests an exposure-dependent effect of current endotoxin exposure on lung function impairment with significant effects above 450 EU/m(3).

Association Between Lung Function and Exposure to Smoke Among Firefighters at Prescribed Burns

We investigated the short-term effects of exposures to PM3.5, acrolein, formaldehyde, and carbon monoxide on lung function in a group of firefighters performing prescribed burns. Spirometric measurements were made on 65 firefighters at the beginning, midpoint, and end of their work shift, while exposure was measured over the entire day. The interquartile range (IQR) of daily personal PM3.5 exposures was 235 μg/m3 to 1317 μg/m3, with an average daily exposure of 882 μg/m3. Concentrations of acrolein (IQR: [0.002, 0.018] ppm), formaldehyde (IQR: [0.008, 0.085] ppm), and carbon monoxide (IQR: [2.10, 10.48] ppm) were similarly elevated. In this group of firefighters, FEV1 changed by −0.125 L from preshift to postshift (p < .001). We examined the association between this cross-shift lung function decrement and smoke exposure. A 1000 μg/m3 increase in PM3.5 was associated with a −0.030 L change in the cross-shift FEV1 (95% CI [−0.087, 0.026]). Acrolein, formaldehyde, and carbon monoxide exposure were also not significantly associated with changes in FEV1, FVC, or FEF25–75. We concluded that while firefighters' lung function significantly decreased from preshift to postshift, firefighters exposed to greater concentrations of respiratory irritants did not experience greater lung function decrements. We could not establish a significant link to any of the individual toxic components of smoke we measured.

Respiratory symptoms and lung function abnormalities among machine operators in automobile production

This cross-sectional study was designed to assess differences in prevalence of respiratory symptoms and lung function between machine operators exposed to semisynthetic or soluble metal-working fluids (MWFs) and unexposed assemblers and to assess exposure-response relationships with MWF type, total aerosol, endotoxin, culturable bacteria and fungi. We evaluated 183 machine operators and 66 assemblers from one large automobile transmission plant using questionnaires, spirometry data, and cross-shift assessment of both lung function and respiratory symptoms. We found that airborne exposures to total aerosol, endotoxin, culturable bacteria and fungi were higher in machine operations than in the assembly area. There was a correlation between bulk and airborne culturable bacteria, but not between bulk and airborne culturable fungi. Machine operators had significantly more usual cough, usual phlegm, work-related chest tightness and post-shift symptoms of chest tightness, throat irritation, and cough compared with assemblers. We found exposure-response relationships between respiratory symptoms and total aerosol, as well as culturable fungi and bacteria. Associations with endotoxin were not strong or consistent, possibly because airborne levels were generally low. Cross-shift lung function decrements did not differ between machine operators and assemblers and there were no associations with MWF or specific exposures. The finding of respiratory symptoms at low levels of exposure in this study suggests the need to re-assess total aerosol thresholds. Associations between airborne fungal exposures and respiratory symptoms need further study to characterize sources of exposure other than MWF in machining operations. Am. J. Ind. Med. 31:403–413, 1997. © 1997 Wiley-Liss, Inc.

Acute pulmonary responses among automobile workers exposed to aerosols of machining fluids.

Previous investigations of workers exposed to machining fluids have shown increased rates of cough and phlegm and have shown that these exposures may cause occupational asthma. To examine acute responses to these agents, cross-shift lung function changes related to machining fluid aerosols among 89 machine operators at two factories producing automobile parts were measured and compared with the findings for 42 unexposed assembly workers studied similarly at the same factories. Workers wore a personal air-sampling device on a Monday and Friday of a working week, and spirometry was performed before and after the work shifts on both days. On Mondays, a 5% or greater decrease in the forced expiratory volume in 1-second (FEV1), regarded as an "FEV1-response," occurred in 23.6% of the machinists and in only 9.5% of the assembly workers (relative risk = 2.5, p less than .05). After adjusting statistically for a history of childhood asthma, for smoking prior to lung function testing, and for race, odds ratios for an FEV1-response of 4.4 among workers exposed to aerosols of straight mineral oils, 5.8 for oil emulsions, and 6.9 for synthetic fluids were found. The FEV1-responses on Fridays were similar to those on Mondays. There was no progressive decline in FEV1 over the work week. Personal air samples, collected with a two-stage impactor, allowed aerosol masses to be measured in three size fractions: less than 3.5 microns, 3.5-9.8 microns, and greater than 9.8 microns aerodynamic diameter. Exposure levels to each type of machining fluid were remarkably similar within each size fraction and for total aerosol levels. Total aerosol concentrations for assembly workers ranged from 0.07 to 0.44 mg/M3, and for machinists from 0.16 to 2.03 mg/m3. Inhalable particle (less than or equal to 9.8 microns) levels were derived from the sum of the air concentrations in the two smallest-size fractions, and significant cross-shift decrements in FEV1 on Mondays and Fridays were associated with inhalable aerosol levels greater than 0.20 mg/m3. These findings show that acute airflow obstruction is associated with exposures to aerosols of various machining fluids and that airway responses occur well below current recommended exposure limits.