Cerevisiae Invertase Research Articles

Effect of flow patterns on recovery of invertases from Saccharomyces cerevisiae using polyethylene glycol/magnesium sulfate system in microchannels

The use of microdevices in extraction processes in aqueous two-phase systems (ATPS) has been studied for years in the literature. However, the effects of flow patterns still need to be adequately explored, especially for real samples. In this sense, the present study investigated the performance of microdevices in the recovery and partial purification of invertases with varying flow patterns. The invertases from Saccharomyces cerevisiae and the polyethylene glycol 1500/magnesium sulfate system were used in the experiments. Beyond the flow pattern, the study sought to maximize recovery and purification factor (PF) values by varying other operating conditions, including residence time, volumetric ratio, and channel diameter. It was observed that the short slug and long slug patterns showed better separation performance than the parallel pattern regardless of residence time and volumetric ratio. Increasing the residence time from 15 to 35 min increased the top recovery and PF values by two times, indicating that S. cerevisiae invertase partition is slow to the top phase. The maximum values of recovery (57.01 % ± 2.67 %) and PF (4.16 ± 0.06) were reached in the condition with long slug pattern, 35 min of operation, volumetric ratio of 2:1, and a channel diameter of 0.51 mm. The present study provides valuable information for integrating microdevices in a protocol for purifying invertase from S. cerevisiae and other proteins in real systems.

Invertase Immobilization on Magnetite Nanoparticles for Efficient Fructooligosaccharide Generation: A Comprehensive Kinetic Analysis and Reactor Design Strategy

This study investigated the effectiveness of immobilizing Saccharomyces cerevisiae invertase (SInv) on magnetite nanoparticles to produce fructooligosaccharides (FOSs). Based on the existing literature and accompanied by parameter estimation, a modified kinetic model was employed to represent the kinetics of sucrose hydrolysis and transfructosylation using SInv immobilized on magnetite nanoparticle surfaces. This model was utilized to simulate the performance of batch reactors for both free and immobilized enzymes. The maximum FOS concentration for the free enzyme was determined to be 123.1 mM, while the immobilized case achieved a slightly higher concentration of 125.4 mM. Furthermore, a continuous stirred-tank reactor (CSTR) model was developed for the immobilized enzyme, resulting in a maximum FOS concentration of 73.96 mM at the reactor’s outlet and a dilution rate of 14.2 h−1. To examine the impact of glucose inhibition on FOS production, a glucose oxidase reaction mechanism was integrated into the fitted immobilized theoretical model. In a batch reactor, the reduction or elimination of glucose in the reactive media led to a 2.1% increase in FOS production. Immobilizing the biocatalyst enhanced the overall performance of SInv. This enzyme immobilization approach also holds the potential for coupling glucose oxidase onto functionalized nanoparticles to minimize glucose inhibition, thereby improving FOS synthesis and facilitating optimal enzyme recovery and reuse.

Protein engineering of invertase for enhancing yeast dough fermentation under high-sucrose conditions.

During yeast dough fermentation, such as the high-sucrose bread-making process, the yeast cells are subjected to considerable osmotic stress, resulting in poor outcomes. Invertase is important for catalyzing the irreversible hydrolysis of sucrose to free glucose and fructose, and decreasing the catalytic activity of the invertase may reduce the glucose osmotic stress on the yeast. In this study, we performed structural design and site-directed mutagenesis (SDM) on the Saccharomyces cerevisiae invertase (ScInV) in an Escherichia coli expression system to study the catalytic activity of ScInV mutants in vitro. In addition, we generated the same mutation sites in the yeast endogenous genome and tested their invertase activity in yeast and dough fermentation ability. Our results indicated that appropriately reduced invertase activity of yeast ScInV can enhance dough fermentation activity under high-sucrose conditions by 52%. Our systems have greatly accelerated the engineering of yeast endogenous enzymes both in vitro and in yeast, and shed light on future metabolic engineering of yeast.

Biochemical characterization and evaluation of invertases produced from Saccharomyces cerevisiae CAT-1 and Rhodotorula mucilaginosa for the production of fructooligosaccharides

Invertases are used for several purposes; one among these is the production of fructooligosaccharides. The aim of this study was to biochemically characterize invertase from industrial Saccharomyces cerevisiae CAT-1 and Rhodotorula mucilaginosa isolated from Cerrado soil. The optimum pH and temperature were 4.0 and 70 °C for Rhodotorula mucilaginosa invertase and 4.5 and 50 °C for Saccharomyces cerevisiae invertase. The pH and thermal stability from 3.0 to 10.5 and 75 °C for R. mucilaginosa invertase, respectively. The pH and thermal stability for S. cerevisiae CAT-1 invertase from 3.0 to 7.0, and 50 °C, respectively. Both enzymes showed good catalytic activity with 10% of ethanol in reaction mixture. The hydrolysis by invertases occurs predominantly when sucrose concentrations are ≤5%. On the other hand, the increase in the concentration of sucrose to levels above 10% results in the highest transferase activity, reaching about 13.3 g/L of nystose by S. cerevisiae invertase and 12.6 g/L by R. mucilaginosa invertase. The results demonstrate the high structural stability of the enzyme produced by R. mucilaginosa, which is an extremely interesting feature that would enable the application of this enzyme in industrial processes.

Kluyveromyces marxianus yeast enables the production of low FODMAP whole wheat breads

There is evidence that a diet low in Fermentable Oligo-, Di-, Monosaccharides And Polyols (FODMAPs) alleviates symptoms in approx. 70% of the patients suffering from irritable bowel syndrome. Through fructans, wheat containing products are a major source of FODMAPs in the western diet. Although fructans are partially degraded during dough fermentation by Saccharomyces cerevisiae invertase, wheat bread contains notable fructan levels. In this study, it was shown that Kluyveromyces marxianus strain CBS6014 can degrade more than 90% of the fructans initially present in wheat whole meal during bread making, which can be attributed to its high inulinase activity. As K. marxianus CBS6014 was not able to consume maltose during fermentation, alternative sugars (sucrose) or glucose releasing enzymes (amyloglucosidase) had to be included in the bread making recipe to ensure sufficient production of CO2 and high bread quality. Five volatile flavor compounds were produced in significantly different levels when K. marxianus CBS6014 was used as starter culture compared with the conventional S. cerevisiae bakery strain. These differences were, however, not detected when sensory analysis of the crumb was performed. This study demonstrates the potential of inulinase-producing K. marxianus strains for the production of (whole meal) breads low in FODMAPs.

Enzymatic synthesis of novel oligosaccharides from N-acetylsucrosamine and melibiose using Aspergillus niger α-galactosidase, and properties of the products.

Two kinds of oligosaccharides, N-acetylraffinosamine (RafNAc) and N-acetylplanteosamine (PlaNAc), were synthesized from N-acetylsucrosamine and melibiose using the transgalactosylation activity of Aspergillus niger α-galactosidase. RafNAc and PlaNAc are novel trisaccharides in which d-glucopyranose residues in raffinose (Raf) and planteose are replaced with N-acetyl-d-glucosamine. These trisaccharides were more stable in acidic solution than Raf. RafNAc was hydrolyzed more rapidly than Raf by α-galactosidase of green coffee bean. In contrast, RafNAc was not hydrolyzed by Saccharomyces cerevisiae invertase, although Raf was hydrolyzed well by this enzyme. These results indicate that the physicochemical properties and steric structure of RafNAc differ considerably from those of Raf.

Cloning and expression of Saccharomyces cerevisiae SUC2 gene in yeast platform and characterization of recombinant enzyme biochemical properties.

Invertase (EC.3.2.1.26) catalyzes the hydrolysis of sucrose to an equimolar mixture of d-glucose and d-fructose which is of interest for various industrial applications. In this research, Saccharomyces cerevisiae invertase gene (SUC2) was optimized based on Pichia pastoris codon preference. The synthetic gene was introduced into the methylotrophic yeast Pichia pastoris under the control of the inducible AOX1 promoter. High level of the extracellular recombinant invertase (R-inv) production was achieved via methanol induction for 4 days and purified by His-Tag affinity chromatography which appeared to be a mixture of glycosylated proteins with various sizes of 85–95 kDa on SDS-PAGE. Deglycosylation of the proteins by Endo-H resulted in the proteins with average molecular weight of 60 kDa. The purified recombinant invertase biochemical properties and kinetic parameters determined a pH and temperature optimum at 4.8 and 60 °C, respectively, which in comparison with native S. cerevisiae invertase, thermal stability of recombinant invertase is highly increased in different heating treatment experiments. The purification of recombinant invertase resulted in an enzyme with specific activity of 178.56 U/mg with 3.83-fold of purification and the kinetic constants for enzyme were Km value of 19 mM and Vmax value of 300 μmol min−1 mg−1 With kinetic efficiency (Kcat/Km) of 13.15 s−1 mmol−1 it can be concluded that recombinant P. pastoris invertase can be more effective for industrial quality criteria. We conclude that recombinant P. pastoris enzyme with broad pH stability, substrate specificity and proper thermal stability can fulfil a series of predefined industrial quality criteria to be used in food, pharmaceutical and bio ethanol production industries.

Hexokinase—A limiting factor in lipid production from fructose in Yarrowia lipolytica

Microbial biolipid production has become an important part of making biofuel production economically feasible. Genetic engineering has been used to improve the ability of Yarrowia lipolytica, an oleaginous yeast, to produce lipids using glucose-based media. However, few studies have examined lipid accumulation by Y. lipolytica׳s ability to utilize other hexose sugars, and as of yet, the rate-limiting steps in this process are unidentified. In this study, we investigated the de novo accumulation of lipids by Y. lipolytica when grown in glucose, fructose, and sucrose. Three Y. lipolytica wild-type (WT) strains of varied origin differed significantly in their lipid production, growth, and fructose utilization. Hexokinase (ylHXK1p) activity partially explained these differences. Overexpression of the ylHXK1 gene led to increased hexokinase activity (6.5–12 times higher) in the mutants versus the WT strains; a pronounced reduction in cell filamentation in mutants grown in fructose-based media; and improved biomass production, particularly in the mutant whose parent had shown the lowest growth capacity in fructose (French strain W29). All mutants showed improved lipid yield and production when grown on fructose, although the effect was strain dependent (23–55% improvement). Finally, we overexpressed ylHXK1 in a highly modified strain of Y. lipolytica W29 engineered to optimize oil production. This modification was combined with Saccharomyces cerevisiae invertase gene expression to evaluate the resulting mutant׳s ability to produce lipids using cheap industrial substrates, namely sucrose (a major component of molasses). Sucrose turned out to be a better substrate than either of its building blocks, glucose or fructose. Over its 96h of growth in the bioreactors, this highly modified strain produced 9.15gL−1 of lipids, yielding 0.262gg−1 of biomass.

Characteristics of extracellular invertase of Saccharomyces cerevisiae in heterologous expression of the suc2 Gene in Solanum tuberosum plants

Some properties and activity of extracellular invertase in the Saccharomyces cerevisiae yeasts encoded by the suc2 gene in heterologous expression were described. It was shown that the target suc2 gene is actively expressed in the genome of the transformed potato plants and S. cerevisiae invertase synthesized by this gene is transported into the apoplast due to the signal peptide of the proteinase II inhibitor. This enzyme is present in the apoplast in a soluble form and absorbed into the cell wall.

Highly Efficient Method Towards In Situ Immobilization of Invertase Using Cryogelation

A novel method was developed for the immobilization of Saccharomyces cerevisiae invertase within supermacroporous polyacrylamide cryogel and was used to produce invert sugar. First, the cross-linking of invertase with soluble polyglutaraldehyde (PGA) was carried out prior to immobilization in order to increase the bulkiness of invertase and thus preventing the leakage of the cross-linked enzyme after immobilization by entrapment. And then, in situ immobilization of PGA cross-linked invertase within cryogel synthesis was achieved by free radical polymerization in semi-frozen state. The method resulted in 100 % immobilization and 74 % activity yields. The immobilized invertase retained all the initial activity for 30 days and 30 batch reactions. Immobilization had no effect on optimum temperature and it was 60 °C for both free and immobilized enzyme. However, optimum pH was affected upon immobilization. Optimum pH values for free and immobilized enzyme were 4.5 and 5.0, respectively. The immobilized enzyme was more stable than the free enzyme at high pH and temperatures. The kinetic parameters for free and immobilized invertase were also determined. The newly developed method is simple yet effective and could be used for the immobilization of some other enzymes and microorganisms.

Porous cross linked enzyme aggregates (p-CLEAs) of Saccharomyces cerevisiae invertase

In this work, porous cross-linked enzyme aggregates (p-CLEAs) of Saccharomyces cerevisiae invertase are reported for the first time. Porous CLEAs were prepared by adding starch as a pore-making agent in crude invertase solution and co-precipitating with invertase using ammonium sulfate as a precipitating agent. The resultant co-precipitate was cross-linked for 8 h with 20 mM glutaraldehyde and in the end starch was removed by alpha amylase. The highest catalytic efficiency was obtained at 0.4% (w/v) starch. The scanning electron microscopy analysis of invertase p-CLEAs showed a porous structure. The p-CLEAs were shown to have improved internal mass transfer compared to conventional CLEAs.

N-terminal chimaeras with signal sequences enhance the functional expression and alter the subcellular localization of heterologous membrane-bound inorganic pyrophosphatases in yeast

Expression of heterologous multispanning membrane proteins in Saccharomyces cerevisiae is a difficult task. Quite often, the use of multicopy plasmids where the foreign gene is under the control of a strong promoter does not guarantee efficient production of the corresponding protein. In the present study, we show that the expression level and/or subcellular localization in S. cerevisiae of a heterologous type of multispanning membrane protein, the proton-translocating inorganic pyrophosphatase (H+-PPase), can be changed by fusing it with various suitable N-terminal signal sequences. Chimaeric proteins were constructed by adding the putative N-terminal extra domain of Trypanosoma cruzi H+-PPase or the bona fide signal sequence of S. cerevisiae invertase Suc2p to H+-PPase polypeptides of different organisms (from bacteria to plants) and expressed in a yeast conditional mutant deficient in its cytosolic PPi hydrolysis activity when grown on glucose. Chimaeric constructs not only substantially enhanced H+-PPase expression levels in transformed mutant cells, but also allowed functional complementation in those cases in which native H+-PPase failed to accomplish it. Activity assays and Western blot analyses demonstrated further the occurrence of most H+-PPase in internal membrane fractions of these cells. The addition of N-terminal signal sequences to the vacuolar H+-PPase AVP1 from the plant Arabidopsis thaliana, a protein efficiently expressed in yeast in its natural form, alters the subcellular distribution of the chimaeras, suggesting further progression along the secretory sorting pathways, as shown by density gradient ultracentrifugation and in vivo fluorescence microscopy of the corresponding GFP (green fluorescent protein)-H+-PPase fusion proteins.

The effect of high electric field pulses on activity of sugar beet o-diphenol oxidase and yeast invertase

Activities of Saccharomyces cerevisiae invertase and sugar beet o-diphenol oxidase were relatively resistant to treatment with high electric field pulses (HEFP) irrespective of the conductivity, pH and concentration of their solutions and the number of electric pulses. The electric field strength ranged between 3 and 60 kV/cm and the number of pulses varied from 1 to 30. The yeast invertase was relatively resistant to HEFP treatment when the electric field strength ranged between 3 and 15 kV/cm since it lost only 10%–20% initial activity. When the electric field strength was increased to 17, 20 and 60 kV/cm, the activity of invertase was decreased by approximately 30%, 90% and 100%, respectively. Activity of o-diphenol oxidase contained in the raw sugar beet juice was not reduced by HEFP treatment.

Immobilization of invertase onto poly(3-methylthienyl methacrylate)/poly(3-thiopheneacetic acid) matrix

A novel immobilization matrix, poly(3-methylthienyl methacrylate)–poly(3-thiopheneacetic acid) (PMTM–PTAA), was synthesized and used for the covalent immobilization of Saccharomyces cerevisiae invertase to produce invert sugar. The immobilization resulted in 87% immobilization efficiency. Optimum conditions for activity were not affected by immobilization and the optimum pH and temperature for both free and immobilized enzyme were found to be 4.5 and 55 °C, respectively. However, immobilized invertase was more stable at high pH and temperatures. The kinetic parameters for free and immobilized invertase were also determined using the Lineweaver–Burk plot. The K m values were 35 and 38 mM for free and immobilized enzyme, respectively. The V max values were 29 and 24 mg glucose/mg enzyme min for free and immobilized enzyme, respectively. Immobilized enzyme could be used for the production of glucose and fructose from sucrose since it retained almost all the initial activity for a month in storage and retained the whole activity in repeated 50 batch reactions.

Redirection of peroxisomal alcohol oxidase ofHansenula polymorphato the secretory pathway

We report on the rerouting of peroxisomal alcohol oxidase (AO) to the secretory pathway of Hansenula polymorpha. Using the leader sequence of the Saccharomyces cerevisiae mating factor alpha (MFalpha) as sorting signal, AO was correctly sorted to the endoplasmic reticulum (ER), which strongly proliferated in these cells. The MFalpha presequence, but not the prosequence, was cleaved from the protein. AO protein was present in the ER as monomers that lacked FAD, and hence was enzymatically inactive. Furthermore, the recombinant AO protein was subject to gradual degradation, possibly because the protein did not fold properly. However, when the S. cerevisiae invertase signal sequence (ISS) was used, secretion of AO protein was observed in conjunction with bulk of the protein being localized to the ER. The amount of secreted AO protein increased with increasing copy numbers of the AO expression cassette integrated into the genome. The secreted AO protein was correctly processed and displayed enzyme activity.

A novel platform for the production of nonhydroxylated gelatins based on the methylotrophic yeastHansenula polymorpha

The use of yeast as a host for heterologous expression of proteins that are normally derived from animal tissue is a promising way to ensure defined products that are devoid of potential harmful animal side products. Here we report on the production and secretion of a custom-designed gelatin, Hu3-His8, by the yeast Hansenula polymorpha. We observed that Hu3-His8 was poorly secreted by the heterologous Saccharomyces cerevisiae invertase secretion signal. In contrast, the S. cerevisiae mating factor alpha prepro sequence efficiently directed secretion into the culture medium. However, at higher copy numbers, intracellular accumulation of Hu3-His8 precursors occurred. Overproduction of Erv29p, a protein required for packaging of the glycosylated pro-alpha factor into COPII vesicles, did not improve gelatin secretion in the multicopy strain. Previously, H. polymorpha was reported to hydroxylate proline residues in gelatinous sequences. In contrast, we were unable to detect hydroxyprolines in the secreted Hu3-His8. Also, we failed to identify a gene encoding prolyl-4-hydroxylase in the H. polymorpha genome.

Immobilization of Chitosan‐Invertase Neoglycoconjugate on Carboxymethylcellulose‐Modified Chitin

Saccharomyces cerevisiae invertase, chemically modified with chitosan, was immobilized on a carboxymethylcellulose‐coated chitin support via polyelectrolyte complex formation. The yield of immobilized protein was determined to be 72% and the enzyme retained 68% of the initial invertase activity. The optimum temperature for invertase was increased by 5°C and its thermostability was enhanced by about 9°C after immobilization. The immobilized enzyme was stable against incubation in high ionic strength solutions and was 12.6‐fold more resistant to thermal treatment at 65°C than the native counterpart. The prepared biocatalyst retained 98% and 100% of the original catalytic activity after 10 cycles of reuse and 70 h of continuous operational regime in a packed bed reactor, respectively. The immobilized enzyme retained 95% of its activity after 50 days of storage at 37°C.

Polyelectrolyte complex formation mediated immobilization of chitosan-invertase neoglycoconjugate on pectin-coated chitin

Saccharomyces cerevisiae invertase, chemically modified with chitosan, was immobilized on pectin-coated chitin support via polyelectrolyte complex formation. The yield of immobilized enzyme protein was determined as 85% and the immobilized biocatalyst retained 97% of the initial chitosan-invertase activity. The optimum temperature for invertase was increased by 10 degrees C and its thermostability was enhanced by about 10 degrees C after immobilization. The immobilized enzyme was stable against incubation in high ionic strength solutions and was 4-fold more resistant to thermal treatment at 65 degrees C than the native counterpart. The biocatalyst prepared retained 96 and 95% of the original catalytic activity after ten cycles of reuse and 74 h of continuous operational regime in a packed bed reactor, respectively.

Immobilization of chitosan-modified invertase on alginate-coated chitin support via polyelectrolyte complex formation

Saccharomyces cerevisiae invertase was chemically modified with chitosan and further immobilized on sodium alginate-coated chitin support. The yield of immobilized protein was determined as 85% and the enzyme retained 97% of the initial chitosan-invertase activity. The optimum temperature for invertase was increased by 10 °C and its thermostability was enhanced by about 9 °C after immobilization. The immobilized enzyme was stable against incubation in high ionic strength solutions and was four-fold more resistant to thermal treatment at 65 °C than the native counterpart. The biocatalyst prepared retained 80% of the original catalytic activity after 50 h under continuous operational regime in a packed bed reactor.

Expression of an Antifungal Peptide in Saccharomyces: A New Approach for Biological Control of the Postharvest Disease Caused by Colletotrichum coccodes

ABSTRACT A cecropin A-based peptide inhibited germination of Colletotrichum coccodes at 50 muM. The DNA sequence encoding the peptide was cloned in pRS413, using the Saccharomyces cerevisiae invertase leader sequence for secretion of the peptide, and expressed in yeast. Yeast transformants inhibited the growth of germinated C. coccodes spores and inhibited decay development caused by C. coccodes in tomato fruits. Expression of the antifungal peptide in yeast therefore represents a new approach for the biological control of postharvest diseases.