Yeast Lipids from Crude Glycerol Media and Utilization of Lipid Fermentation Wastewater as Maceration Water in Cultures of Edible and Medicinal Mushrooms

Abstract

Four wild “red” yeast strains (Rhodosporidium kratochvilovae FMCC Y70, R. toruloides NRRL Y-27013, R. toruloides NRRL Y-17902 and R. toruloides NRRL Y-6985) were cultured in shake flasks on industrial glycerol at an initial substrate (Gly0) concentration ≈ 50 g/L under nitrogen limitation. Strains NRRL Y-27013, NRRL Y-17902 and NRRL Y-6985 presented appreciable dry cell weight (DCW) and lipid synthesis (DCW up to 18–19 g/L containing lipids in quantities ≈ 47%, w/w). Strains NRRL Y-27013 and NRRL Y-6985 were further tested in higher Gly0 concentrations (≈90 g/L and ≈110 g/L) with the same initial nitrogen quantity as in the first (“screening”) experiment. Both strains, despite the high Gly0 concentrations and C/N ratios (up to 120 moles/moles) imposed, presented significant DCW production (up to c. 29.0–29.5 g/L). Yeast biomass contained significant lipid (42–43%, w/w) and endopolysaccharide (up to 42%, w/w) quantities. Both lipids and endopolysaccharide quantities (in % w/w) noticeably increased as a response to the imposed nitrogen limitation. Lipids containing mainly oleic and palmitic acids constituted ideal candidates for biodiesel synthesis. Thereafter, the wastewaters derived from the lipid production process (lipid fermentation wastewaters—LFWs) were used as maceration waters in cultivations of edible and medicinal fungi, where novel (non-conventional) substrates were used in the performed cultures. CW (coffee residue + wheat straw), CB (coffee residue + beech wood shavings), OW (olive crop + wheat straw), OB (olive crop + beech wood shavings), RW (rice husk + wheat straw) and RB (rice husk + beech wood shavings) were soaked/sprayed with LFWs or tap water and utilized in the cultivation of Pleurotus, Ganoderma and Lentinula mushrooms. The impact of LFWs on the mycelial growth rate (mm/d) and biomass production was evaluated. The results show that regardless of the wetting method, the highest growth rates (6.2–6.6 mm/d) were noticed on RW and RB for Pleurotus eryngii and Ganoderma resinaceum, on OW, OB and RW for Ganoderma applanatum and on RW, OW and OB for Lentinula edodes. Nevertheless, high biomass production was obtained on substrates soaked with LFWs for Pleurotus ostreatus (RW: 443 mg/g d.w.), L. edodes (RB: 238 mg/g d.w.) and Ganoderma lucidum (RW: 450 mg/g d.w.). Overall, this study demonstrates the possibility of the industrial conversion of low-value agro-waste to mycelial mass and eventually to important food products.