Wheat bran particle size influence on phytochemical extractability and antioxidant properties

Abstract

It is unknown if particle size plays a role in extracting health promoting compounds in wheat bran because the extraction of antioxidant and phenolic compounds with particle size reduction has not been well documented. In this study, unmilled whole bran (coarse treatment) was compared to whole bran milled to medium and fine treatments from the same wheat bran. Antioxidant properties (capacity, ability, power), carotenoids and phenolic compounds (phenolic acids, flavonoids, anthocyanins) were measured and compared. The ability of whole bran fractions of differing particle size distributions to inhibit free radicals was assessed using four in vitro models, namely, diphenylpicrylhydrazyl radical-scavenging activity, ferric reducing/antioxidant power (FRAP) assay, oxygen radical absorbance capacity (ORAC), and total antioxidant capacity. Significant differences in phytochemical concentrations and antioxidant properties were observed between whole bran fractions of reduced particle size distribution for some assays. The coarse treatment exhibited significantly higher antioxidant properties compared to the fine treatment; except for the ORAC value, in which coarse was significantly lower. For soluble and bound extractions, the coarse treatment was comparatively higher in total antioxidant capacity (426.72mg ascorbic acid eq./g) and FRAP value (53.04μmol FeSO4/g) than bran milled to the finer treatment (314.55 ascorbic acid eq./g and 40.84μmol FeSO4/g, respectively). Likewise, the fine treatment was higher in phenolic acid (7.36mg FAE/g), flavonoid (206.74μg catechin/g), anthocyanin (63.0μg/g), and carotenoid contents (beta carotene, 14.25μg/100g; zeaxanthin, 35.21μg/100g; lutein 174.59μg/100g) as compared to the coarse treatment. An increase of surface area to mass increased the ORAC value by over 80%. With reduction in particle size, there was a significant increase in extracted anthocyanins, carotenoids and ORAC value. Particle size does effect the extraction of phytochemicals.