UV assisted photoelectrocatalytic oxidation of phthalic acid using spray deposited Al doped zinc oxide thin films

Abstract

Undoped and Al doped ZnO (AZO) thin films are successfully prepared by spray pyrolysis technique at optimised substrate temperature of 400°C onto amorphous and F:SnO2 coated glass substrates. Effect of Al doping on structural, morphological and optical properties of ZnO thin films is studied. Deposited films are polycrystalline with a hexagonal (wurtzite) crystal structure having (002) preferred orientation. The PEC characterization shows that, short circuit current (Isc) and open circuit voltage (Voc) are (Isc=0.38mA and Voc=421mV) relatively higher at the 3at.% Al doping. SEM images show deposited thin films are compact and uniform with seed like grains. All films exhibit average transmittance of about 82% in the visible region and a sharp absorption onset at 375nm corresponding to 3.3eV. The photocatalytic activities of the large surface area (64cm2) Al-doped ZnO photocatalyst samples were evaluated by photoelectrocatalytic degradation of phthalic acid under UV light irradiation. The results show that the 3at.% AZO thin film photocatalyst exhibited degradation of phthalic acid up to about 45% within 3h with significant reduction in COD and TOC values.