Utilization of palm oil mill effluent as a novel substrate for the production of antifungal compounds by Streptomyces philanthi RM-1-138 and evaluation of its efficacy in suppression of three strains of oil palm pathogen.

Abstract

This study aimed to use palm oil mill effluent (POME) as a renewable resource for the production of antifungal compounds by Streptomyces philanthi RM-1-138 against Ganoderma boninense, Ceratocystis paradoxa and Curvularia oryzae. The efficacy of antifungal compounds RM-1-138 against the three strains of fungal oil palm pathogen was evaluated both in vitro and on oil palm leaf segments. In vitro studies using confrontation tests on glucose yeast-malt extract (GYM) agar plates indicated that the strain RM-1-138 inhibited the growth of all three fungal pathogenic strains. The antifungal compounds produced in the GYM medium exhibited significantly higher inhibition (79%-100%) against the three fungal pathogens than using the diluted POME (50%) medium (80%-83% inhibition). The optimum condition for the production of antifungal compounds from the strain RM-1-138 was as following: POME of 47,966mgL-1 chemical oxygen demand (COD), the initial pH at 7.0 and supplemented with yeast extract (0.4%). Meanwhile, severe morphological and internal abnormalities in C. oryzae hyphae were observed under a scanning electron microscope and transmission electron microscope. In vivo experiment on oil palm leaf segments indicated that the efficacy of the antifungal compounds RM-1-138 (DSI=1.3) were not significantly difference in the suppression of Curvularia leaf spot compared with the two commercial chemical fungicides of mancozeb® (DSI=1.0) and tetraconazole® (DSI=1.3). Antifungal compounds produced by S. philanthi RM-1-138grown in POME have the potential to inhibit fungal pathogens. The POME (about 47mgL-1 COD) with the initial pH of 7.0 and supplementation of 0.4% nitrogen could be used as a culture medium for the growth and production of antifungal compounds of S. philanthi RL-1-138. In addition, the antifungal compound RM-1-138 could suppress the three strains of oil palm fungal pathogen tested on oil palm leaf segment.