Understanding the Impact of Monsoon Season in Malaysia Water Based on Data Analytics for Planning and Executing Drilling Operation

Abstract

Abstract Drilling operation in Malaysia are typically from offshore, thus offshore weather condition does contributed to the success or delay of a drilling operation. Wait on Weather (WOW) especially during monsoon season in Malaysia has impacted Operator's drilling operation, thus incurring additional cost to Operator. Monsoon season in Malaysia is typically from November to February every year. This paper will discuss and share the statistics of actual WOW happening from 2008 to 2019 in Malaysia water especially for jack-up rig (JUR) and tender assisted drilling rig (TADR) which are two common rigs in Malaysia water. The data was collected from one of the drilling operator in Malaysia. These data will be of assistance to Operator in better planning and executing drilling operation with the actual statistics as the risk factor. WOW is considered as non-productive time (NPT), thus NPT data gathering from Operators in Malaysia water were conducted. Data was then filtered to achieve the WOW data. WOW data was segregated between region in Malaysia which are Peninsular Malaysia (PM), Sabah (SB) and Sarawak (SK) as well as rig type, which are JUR and TADR. Distribution analysis were made to calculate the average and observe the maximum numbers of actual WOW occurrence. Further analysis was made to zoom into monsoon season in Malaysia which typically in November to February. 11 years data is generally good coverage for the analysis since it covers the up and down of oil and gas industry. Analysis was also done for both mob/demob and operation stage where it can be observed that WOW for mob/demob stage during monsoon season is significantly higher compared to operation stage. At the end of the analysis, the average or maximum numbers of WOW will be shared, and it will be used as recommendation for future projects to consider these figures as WOW risk factor and embed in the planning stage. This paper will help not only Operators in Malaysia water but the host authority on understanding the WOW risk factor during monsoon season. As WOW is not something that can be predicted, utilizing the standard results from actual statistic data for the past 11 years will assist engineers to incorporate the WOW risk factor during planning and execution stage. Rig and project sequencing can be optimized with understanding of WOW impact thus reducing the value leakage during operation due to WOW.