Ultrasonic treatment of waste activated sludge

Abstract

AbstractActivated sludge processes are key technologies to treat wastewater. These biological processes produce huge amounts of waste activated sludge (WAS), now commonly called biosolids. Mechanical, thermal, and/or chemical WAS conditioning techniques have been proposed to reduce the sludge burden. The ultrasonic treatment of WAS is quite novel.The present paper reports on extensive investigations using an ultrasonic treatment of WAS, to study its potential to meet one or all of four objectives: (1) reduce WAS quantities; (2) achieve a better dewaterability; (3) provoke a release of soluble chemical oxygen demand (COD) from the biosolids, preferably transformed into biodegradable organics; and (4) possibly destroy the filamentous microorganisms responsible for sludge bulking. Although meeting these objectives would help to solve the problems cited, the energy consumption could be a considerable drawback: the paper will thus assess whether all or some objectives are met, and at what operational cost.A literature survey defines the occurring phenomena (cavitation) and the important operation parameters [such as frequency, duration, specific energy input (SE)].The experiments are carried out in a batch reactor of volume up to 2.3 L. The ultrasonic equipment consisted of a generator, a converter, and a sonotrode, supplied by Alpha Ultrasonics under the brand name of Telsonic. Three different kinds of sludge were tested, with different concentrations of dry solids (DS) between approximately 3.5 and 14 g DS/L WAS. Ultrasonic energy was introduced in a continuous manner (against possible pulsed operation). The major operational parameters studied include duration of the ultrasonic treatment and specific energy input. The applied frequency was set at 20 kHz.The release of COD from the WAS phase into the filtrate phase is a function of the specific energy input with yields of nearly 30% achievable at SE values of 30,000 kJ/kg DS. A major fraction of the COD is transformed into biodegradable organics (BOD). The reduction in DS fraction of the sludge is proportional to the COD release rates.Although the DS content is reduced, the dewaterability of the sludge is not improved. This reflects itself in increased filtration times during vacuum filtration and in increased values of the capillary suction time (CST). This more difficult dewaterability is the result of considerably reduced floc sizes, offering an extended surface area: more surface water is bound (CST increases) and the filterability decreases as a result of clogging of the cake. To reach the same dryness as for the untreated cake, the required dosage of polyelectrolyte is nearly doubled when the SE of the ultrasound treatment is increased from 7500 to 20,000 kJ/kg DS.The ultrasonic reduction of filamentous WAS organisms is not conclusive and very little effect is seen at low intensities and short treatment durations. Microscopic analysis of the WAS identified the dominant presence of Actynomyces.The release of soluble COD and BOD certainly merit further research. © 2006 American Institute of Chemical Engineers Environ Prog, 2006