Tracing the regulated emissions of field-aged gasoline/natural gas bi-fuel taxis from new to 160,000 km: Deterioration and environmental implications

Abstract

Natural gas (NG) is considered an economically viable transport decarbonization option, especially for developing countries. However, as per the ongoing European and Chinese vehicle emission regulations, the durability and in-service compliance tests of the exhaust emissions from gasoline/NG bi-fuel vehicles are only mandated in gasoline mode, leaving the real-world emission performance of NG fueling at risk. To bridge this gap, the exhaust emissions from five gasoline/NG bi-fuel taxis were traced from new (less than 10,000 km) to 160,000 km after every 10,000 km of field driving. Both room-temperature cold-start and warm-start chassis dynamometer tests were performed over the certification drive cycle. This tracing study lasted for 3.5 years and covered the variations of seasons, routine services, and minor repairs. The results manifested that compared to gasoline fueling, NG had statistically lower carbon monoxide before 100,000 km of driving but higher total hydrocarbon and nitrogen oxides emissions throughout the useful life in both cold- and warm-start tests. By applying linear regression to the data points obtained across the 160,000 km tracing, NG fueling showed a noticeably quicker deterioration with mileage than gasoline. However, given that gasoline and NG modes shared the same catalysts, this is attributed to the less careful calibration of NG mode predominantly because of the void of regulatory requirements. On average, NG fueling produced about 20 % less carbon dioxide emissions than gasoline, but the observed fuel leakage in NG mode partially offset the global warming potential advantage. Overall, NG sees benefits and challenges in mitigating vehicle-related environmental issues. To better control this risk, it is strongly recommended that in future regulations, the durability and in-service compliance requirements of NG fueling shall be complemented, and fuel leakage shall be included in the control of evaporative emissions.