Tocopherols in cocoa butter obtained from cocoa bean roasted in different forms and under various process parameters

Abstract

Obtaining good quality chocolate strongly depends on raw material, i.e. cocoa beans. The processing of cocoa beans consists of some important steps, including fermentation, drying fermented beans and roasting. Traditionally roasting is performed on whole beans but currently, roasting crushed cocoa beans or cocoa liquor becomes more and more popular. Many biologically active compounds may be found in the cocoa beans, including tocopherols. This work investigates the influence of the constant or variable roasting process parameters (temperature, velocity and relative humidity of roasting air) on the tocopherol concentration in cocoa butter (CB) extracted from cocoa beans originating from Togo and roasted in two different forms, namely as whole and crushed beans. Whole cocoa beans were roasted to a 2% moisture content and crushed cocoa beans were firstly partially dried which further enables easier dehusking, then ground, dehusked and roasted until their humidity decreased to around 2%. Roasting resulted in lowering the content of individual tocopherols in analyzed material. The degree of degradation of tocopherols in CBs was different, depending on the form of roasted beans from which these CBs were extracted. Higher concentrations were determined in CBs extracted from beans roasted in the form of crushed samples comparing to CBs obtained from beans roasted as a whole. The study investigates different roasting parameters of crushed beans, none of which drastically lowered the concentration of tocopherols in extracted CBs. Their concentration in CBs extracted from whole beans was, on the other hand, influenced by roasting air parameters. In case of whole beans roasted under constant parameters, application of 150°C proved to be more favorable than roasting at 135°C, as well as application of “dry” air and 1m/s roasting air velocity. Discussing the variable roasting process parameters, in case of applied roasting temperature it is more favorable to change it from 150°C to 135°C, than the other way round. Changing the relative humidity of roasting air from 5 to 0.3%, lower degradation of tocopherols in CB occurs when the process is conducted at 150°C. It may be further concluded that a direct dependence between the velocity of roasting air varied during the process and the concentration of tocopherols in extracted CB may not be indicated. In conclusion, it is stated that the temperature of the air applied during the roasting process has the decisive influence on the tocopherol content in CBs extracted from cocoa beans subjected to the process.