Theoretical and experimental investigation of biomass gasification process in a fixed bed gasifier

Abstract

This investigation concerns the process of air biomass gasification in a fixed bed gasifier. Theoretical equilibrium calculations and experimental investigation of the composition of syngas were carried out and compared with findings of other researchers. The influence of excess air ratio (λ) and parameters of biomass on the composition of syngas were investigated. A theoretical model is proposed, based on the equilibrium and thermodynamic balance of the gasification zone. The experimental investigation was carried out at a setup that consists of a gasifier connected by a pipe with a water boiler fired with coal (50 kWth). Syngas obtained in the gasifier is supplied into the coal firing zone of the boiler, and co-combusted with coal. The moisture content in biomass and excess air ratio of the gasification process are crucial parameters, determining the composition of syngas. Another important parameter is the kind of applied biomass. Despite similar compositions and dimensions of the two investigated feedstocks (wood pellets and oats husk pellets), compositions of syngas obtained in the case of these fuels were different. On the basis of tests it may be stated that oats husk pellets are not a suitable fuel for the purpose of gasification.