The response of GS-NS0 myeloma cells to single and multiple pH perturbations.

Abstract

Animal cells are cultured in several types of vessels at laboratory and industrial scale the most common being the stirred tank and the air-lift. Economically, it is preferable to culture animal cells at the largest possible scale but the perceived sensitivity of animal cells to hydrodynamic shear has, until now, limited the aeration and agitation rates used. This has been reported to cause inhomogeneities in operational parameters such as dissolved oxygen concentration, temperature and pH. pH is of special interest during the latter stages of many animal cell fermentation because alkali additions, used for pH control, can cause large local pH perturbations of varying size and duration. The effect of single and multiple pH perturbations on the cell growth of a widely used GS-NS0 mouse myeloma cell line grown in batch culture was investigated. The effect of perturbation amplitude and duration was investigated using a single stirred tank reactor (STR). In the single STR system cells were subjected to one pH 8.0 or 9.0 perturbation ranging in duration from 0-90 minutes. No measurable decrease in viable cell number was seen for pH 8.0 perturbations of any duration whereas pH 9.0 perturbations lasting for 10 minutes caused a 15% decrease in viable cell number. The proportion of viable cells decreased with increasing perturbation time and a 90-minute exposure killed all of the cells. The effect of multiple pH perturbations on GS-NS0 cells was investigated using two connected STR's. More specifically the number of perturbations and the perturbation frequency were investigated. Cells were subjected to between 0 and 100 perturbations at pH 8.0; the time between each perturbation (frequency) was 6 minutes and each perturbation lasted for 200 seconds. Viable cell number decreased with increasing perturbation number, with 100 perturbations causing death of 27.5% of cells. Cells were also exposed to 10 perturbations at pH 9.0, each of 200 second duration at frequencies of either 6, 18 or 60 minutes. Approximately 8 times more cells were killed with perturbations at a 6-minute frequency (28.3% cell death) than at a 60-minute frequency (3.4% cell death).