The effect of pre-treatment and anaerobic digestion for pathogens reduction in agricultural utilization of sewage sludge

Abstract

The aim of the research work was to explain the possibilities of application of waste activated sludge (WAS) pretreatment processes prior to anaerobic digestion (mesophilic fermentation). Hydrodynamic disintegration and freezing/thawing disintegration methods were used. Based on the microbiological and parasitological analyses, a significant decrease in pathogenic bacteria, coliphages, and parasite eggs was observed. The number of bacteria analyzed (Salmonella sp., Escherichia coli, Clostridium perfringens) and coliphages were reduced from 19.3to 42.3% after hydrodynamic cavitation. A similar effect was achieved for destruction by freezing/thawing with dry ice between 7.8 and 14.9%. The effectiveness of parasite eggs reduction (Ascaris sp., Trichuris sp., Toxocara sp.) for these disintegration methods ranged from 10.7 to 29.3%. The highest results were observed for the hybrid disintegration method (hydrodynamic cavitation + dry ice disintegration) caused by a synergistic effect. Salmonella sp. in 1 gd.w. decrease about 69.7%, E. coli by 70.0%, Clostridium perfringens by 38.4%, and coliphages by 48.2%. Disruption of WAS by a hybrid method led to a reduction in the number of helminth eggs Ascaris sp. (63.8%), Trichuris sp. (64.3%), and Toxocara sp. (66.4%). After anaerobic digestion under mesophilic conditions, an additional reduction of analyzed bacterial pathogens and helminth eggs were observed. The introduction of hybrid disintegrated WAS to the fermentation chamber resulted in higher efficiency in decrease (from 1 to 23%) in comparison to the control sample (70%WAS + 30%DS (inoculum-digested sludge)).