The effect of feed processing of novel unheated, low trypsin inhibitor soybeans on the performance of young female turkeys reared from hatch to 21 days of age

Abstract

The objective of this study was to evaluate the effects of dietary inclusion of a novel low trypsin inhibitor soybean (LTI) fed as mash or crumbled pellet form on the productive performance and digestibility in turkey poults from hatch to 21 d. A total of 336 Hybrid Converter turkey poults were allocated in groups of 7 to 6 treatments, each with 8 replicate cages. Treatments were arranged as a 3 × 2 factorial with inclusion level of the low trypsin-inhibitor soybean (0, 20, and 40% LTI) and feed form (mash and crumbled pellet). A single batch of feed was mixed for each inclusion level and divided into 2 aliquots: one remaining as mash and the other conditioned at 82°C for approximately 30 s, pelleted and then crumbled. On d 7, 14, and 21 posthatching, BW, and feed intake (FI) were recorded and BW gain (BWG) and feed conversion ratio (FCR) calculated. Excreta samples were collected from d 19 to 21 and pooled by cage. At d 21, intestines were excised, pancreas weights recorded (PRW), and ileal contents collected. There were no interactions (linear, P > 0.05) between LTI inclusion and feed form on BW, BWG, FI, or FCR at d 7 or 21. Increasing LTI resulted in a linear reduction in BW at 7, 14, and 21 d (P < 0.006). Poults fed crumbles were significantly heavier at d 21 than those fed mash feed (P < 0.027) with no interaction of LTI level with feed form. FCR was not significantly greater with increasing LTI. However, poults fed crumbles had a better, lower FCR that those fed mash feed from d 0 to 21 (P < 0.018). There was a significant interaction between feed form and LTI level at 14 d (P < 0.031), but not 7 or 21 d. Pancreatic hypertrophy (PRW) increased linearly with increasing LTI (P < 0.001) with a significant linear interaction with feed form (P < 0.001). Poults fed crumbles had less pancreatic hypertrophy. At 21 d of age, dietary fat digestibility (ALD, %) was linearly reduced with increasing LTI (P < 0.001). However, poults fed crumbles had significantly better fat absorption than poults fed mash (91.2 vs. 85.8%) (P < 0.001), and there was a significant linear interaction between feed form and LTI level (P < 0.001). AMEn was significantly better for the poults fed crumbles compared to mash (3228 vs. 3132 kcal/kg) (P < 0.001), and there was a significant linear interaction between feed form and LTI level (P < 0.001). Based on the results this trial, it is possible to include up to 20% unheated full fat LTI soybeans into poult starter diets after pelleting. Pelleting improves nutrient utilization, allowing for greater incorporation of the LTI soybean in the crumbled diet compared to the mash diet.