The combined effect of high hydrostatic pressure, heat and bacteriocins on inactivation of foodborne pathogens in milk and orange juice

Abstract

The objective of this study was to combine pressure (345 MPa) with heat (50 ∘C), and bacteriocins (5000 AU/ml sample) for a short time (5 min) for the inactivation of relatively pressure-resistant strains of four foodborne pathogens: Staphylococcus aureus, Listeria monocytogenes, Escherichia coli O157:H7 and Salmonella in pasteurized milk and orange juice. Without bacteriocin addition, 5.5 log-cycle reduction was obtained for S. aureus 485 in milk whereas more than 8 log-cycle reduction was achieved for all the other strains studied. After storage of samples for 24 h at 4 ∘C, S. aureus 765 also gave positive results on selective media, where no growth was observed for all the other micro-organisms assayed. Incubation of the same pressurized samples at 37 ∘C for 48 h showed growth of L. monocytogenes strains in addition to S. aureus strains, where still no growth was observed for E. coli O157:H7 and Salmonella strains in their respective selective media. For orange juice samples, more than 8 log-cycle reduction was achieved for all the bacterial species studied. No growth was seen for these species on their respective selective media agar plates after storage at 4 ∘C for 24 h and at 37 ∘C for 48 h. When a bacteriocin-based biopreservative (BP1) was combined with pressurization, more than 8 log-cycle reduction in cell population of the resistant strains of S. aureus and L. monocytogenes were achieved in milk after pressurization. Milk samples were stored at 25 ∘C up to 30 days to test the effect of treatment and samples showed no growth whereas all the controls were positive.