The advantages of co-digestion of vegetable oil industry by-products and sewage sludge: Biogas production potential, kinetic analysis and digestate valorisation.

Abstract

The production of edible vegetable oils generates considerable amounts of energy-rich waste, which is usually not utilised fully. Besides, inefficient management of such wastes can have a negative impact on the environment. On the other hand, this waste can also serve as a raw material for the production of high value-added products, such is biogas. The mono-digestion of seven different by-products and wastes from the vegetable oil industry was investigated in this study: Pumpkin seeds press cake (PSPC), grape seeds press cake (GSPC), olive mill pomace (OMP), coconut oil cake (CC), filtration additive (FA), spent bleaching earth (SBE) and sludge from a vegetable oil industry (SOI) wastewater treatment plant. In addition, co-digestion of these substrates was performed with municipal sewage sludge (SS). Besides inoculum, rumen fluid was added to the reactors to enhance biogas production. The biogas production potential of the tested substrates was monitored by measuring various parameters. A kinetic analysis was later carried out and a growth test was performed on the digestates to evaluate their potential for agricultural use. The highest biogas yields in the mono-digestion test were obtained with the substrates with the highest fat content: 1402, 1288, 830 and 750mL of biogas/gVS for SOI, FA, PSPC and CC substrate, respectively. Co-digestion of SS with by-products of vegetable oil industry such as FA, SBE, CC, SOI and PSPC increased the biogas yields by 94.9%, 74.1%, 30.8%, 27.4% and 23.6% compared to SS mono-digestion. Furthermore, the data for mono-digestion of PSPC, GSPC, and FA, and co-digestion of SS with these substrates, CC and SBE, have not been found in the literature to date. The maximum methane content ranged from 61 to 74vol%, while the chemical oxygen demand removal efficiency ranged from 42 to 78%. Relatively high fatty acids contents and ammonium concentrations were measured in the reactors. Kinetic analysis showed the best fit to the experimental data for the Cone kinetic model (R2>0.98). The First order kinetic model, Monod, and the modified Gompertz model also exhibited high R2 values. The digestates obtained from co-digestion proved to be excellent in the cress seeds growth test at digestate concentrations of 5-10wt%, while higher concentrations had a toxic effect.