Testing an aerobic fluidized biofilm process to treat intermittent flows of oil polluted wastewater

Abstract

An aerobic fluidized biofilm process of treating oil-polluted wastewater has been studied. A series of batch experiments were conducted using synthetic wastewater and the kinetic coefficients were evaluated. The maximum rate of substrate utilization per unit mass microorganisms (K) was 1.6 days-1, the substrate concentration at one-half the maximum growth rate (Ks) was 26 mg/L, the maximum specific growth rate (m) was 1.0 days-1, the ratio of the mass cells formed to the mass of substrate consumed (Y) was 0.61, and the endogenous decay coefficient (Kd ) was 0.044 days-1. The kinetic coefficients obtained were within the range of municipal wastewater. It was observed that up to 1500 mg/L oil (Motor oil SAE–40) could be degraded in a fluidized bed bioreactor (FBBR). The experiments, however, were limited to the oil concentration within a range of 1000-2600 mg/L. Average biofilm thickness () under specific conditions was found to be 22 m and average oil degradation rate of 0.053 mg oil/mg biomass/hour was measured in the FBBR. The results also support that the increase in the concentration of oil in the treatment process reduced significantly the degradation rate of non-oil carbon.