Temporal Variations of Air Quality in Cage-Free Experimental Pullet Houses

Abstract

The welfare of laying hens in conventional caged houses has become an increased public concern, leading primary food chains, restaurants, and grocers in the United States to pledge to source only cage-free (CF) eggs by 2025 or 2030. Cage-free housing systems have been considered as a more humane alternative; however, they still come with certain challenges. One of the primary challenges with CF housing is the poor indoor air quality due to the high levels of ammonia (NH3) and particulate matter (PM). Despite the importance of air quality in animal welfare, most studies have focused on the egg-laying stage, thereby leaving a significant knowledge gap in the pullet phase. Addressing this gap is essential to ensure the well-being of laying hens in CF housing and to help producers and researchers identify effective strategies to mitigate the impact of poor indoor air quality on the bird’s health and welfare. Therefore, the objective of this study was to (a) examine the effect of the pullets’ age on NH3 and PM levels, and (b) find the effect of housing, litter moisture content (LMC), and relative humidity (RH) on air pollutant concentrations. The results show that the PM levels of PM2.5, PM10, and total suspended particles (TSP) increased significantly with the growth of birds from 1 to 16 weeks of age (WOA) (p < 0.01). For instance, PM2.5, PM10, and TSP levels were measured at 0.023 ± 0.003, 0.031 ± 0.004, and 0.058 ± 0.013 mg m−3 in the first week, and these levels increased to 1.44 ± 0.58, 2.723 ± 1.094, and 6.39 ± 2.96 mg m−3, respectively, by 16 WOA. In addition, PM levels measured near the perch were found to be three times higher than other locations inside the rooms (e.g., between the feeder and drinker or near the exhaust fan) (p < 0.01), as perching is one of the primary reasons for dust generation. Furthermore, a significant interaction between the age of the pullets and PM levels was found (p < 0.01), as the litter quality and the behaviors of birds were changing over time. For NH3 levels, average daily concentrations were lower than 1 ppm at 16 WOA for all rooms due to dry litter conditions (i.e., 9–10% LMC). Additionally, RH has been shown to have a significant effect on air pollutant concentration. Overall, the results indicate that the bird’s age significantly affects PM generation and PM variation within the rooms. The variation of PM was directly affected by RH inside the house. Therefore, this research will provide valuable information for both researchers and producers to control air pollutant emissions from the pullet stage in CF housing to ultimately improve the health and welfare of hens.