Synergistic pseudo-hydroxide extraction: synergism and anion selectivity in sodium extraction using a crown ether and a series of weak lipophilic acids.

Abstract

The nature of the weak lipophilic acid used in synergistic combination with a model crown ether cation host was shown to have a strong effect on the strength and selectivity of sodium hydroxide separation from alkaline aqueous salt solutions. Sodium ion-pair extraction employing only cis-syn-cis-dicyclohexano-18-crown-6 (1) in nitrobenzene (NB) was correlated with the standard Gibbs energy (deltaG(p)o) of anion partitioning into NB and was notably weak and nonselective for the hydroxide ion, in accord with Hofmeister bias. The Hofmeister order can be selectively overcome for NaOH by utilization of acid-base chemistry coupled with complexation of sodium ion in the NB phase. Upon addition of a lipophilic organic acid into the solution of 1 in NB, sodium extraction was selectively enhanced due to the initiation of an exchange reaction between the aqueous sodium ion and the ionizable proton of the organic acid. A series of weak lipophilic hydroxy acids (HA) including fluorinated alcohols and phenols was tested. The resulting synergistic pseudo-hydroxide extraction correlates with the pKa of the employed HA; the most acidic cation exchangers provide the greatest synergism. The synergistic factor obtained using a fluorinated benzyl alcohol 7 was as high as 256. Ion-pair extraction of neutral sodium salts was not changed or only mildly enhanced by addition of HA into the NB solution of 1. This enhancement was explained by hydrogen bonding of HA with the anion as related to the hardness of the anion and the acidity of HA. In comparison with the synergism observed for NaOH, this enhancement was weak and unable to overcome the Hofmeister effect. Examination of extraction selectivity revealed that the combination of 1 and 7 preferentially extracted NaOH over all other sodium salts, including the normally preferred nitrate and perchlorate salts. Quantitative recovery of NaOH from the NB phase was demonstrated via hydrolysis of the organic acid upon a single contact of the loaded solvent with water.