Synergistic Effect of Field Emission Properties on Growth of CNTs by One-Pot Preparation of Various Concentrations Composite Catalyst

Abstract

Multi-walled carbon nanotubes (MWCNTs) were grown on Silicon (Si) substrate by using low-pressure chemical vapor deposition (LPCVD) technique where iron (Fe) and silver (Ag) colloidal solution act as a catalyst were prepared by chemical route. The as-prepared solutions in varied concentrations were deposited on a Si substrate using a spin coating process at 700[Formula: see text]rpm. The purpose of Fe in composite catalysts is to have high carbon solubility and diffusion rate, and Ag utilization can change catalyst activity temperature and enhance carbon yields. In this work, we demonstrate the growth of carbon nanotubes (CNTs) on different catalyst concentrations ([Formula: see text]Fe/[Formula: see text]Ag), ([Formula: see text]Fe/[Formula: see text]Ag), ([Formula: see text]Fe/[Formula: see text]Ag) and ([Formula: see text]Fe/[Formula: see text]Ag) catalytic films. Field Emission Scanning Electron Microscopy (FESEM) was used to image the morphologies of various catalyst concentrations MWCNTs. The natures of the synthesized CNTs were determined using Raman spectroscopy and it was revealed that as-prepared CNTs are MWCNTs due to the absence of radial breathing mode (RBM). Raman spectroscopy demonstrated the lower ID/IG ratio (Ratio of the intensity of D-Raman peak and G-Raman peak) of ([Formula: see text]Fe/[Formula: see text]Ag) MWCNTs. The ID/IG ratio for ([Formula: see text]Fe/[Formula: see text]Ag) catalyzed MWCNTs was 0.76, while the ID/IG ratio for ([Formula: see text]Fe/[Formula: see text]Ag) catalyzed MWCNTs was 0.89. The ([Formula: see text]Fe/[Formula: see text]Ag) catalyzed MWCNTs were found to be more defective as compared to other. Electron Emission from ([Formula: see text]Fe/[Formula: see text]Ag) catalyzed MWCNTs were much stronger than from other samples, as demonstrated by Field Emission measurement using diode configuration. The turn-on field for ([Formula: see text]Fe/[Formula: see text]Ag) catalyzed MWCNTs was (0.92 V/[Formula: see text]m) which is slightly lower than that of ([Formula: see text]Fe/[Formula: see text]Ag) catalyzed MWCNTs (1.83 V/[Formula: see text]m), indicating superior enhancement.