Study on the influence of seating orientation during frontal impacts by child occupant human body model response analysis

Abstract

Objective Autonomous driving cars must be developed to ensure that children will have the highest level of protection in case of collision. Changes to the vehicle cabin design (different seat orientations, fully reclining seats, etc.) may significantly impact child occupant safety. Understanding child occupant responses under these new conditions is necessary to decrease risk and enhance child safety. In this study, child occupant response in different seating orientations exposed to frontal impacts with a focus on the head injuries and kinematics was analyzed. Methods Finite elements simulations were performed using the PIPER 6-year-old human body model (HBM). All simulations were carried out in a generic full vehicle environment. The child model was positioned in an adequate generic car restraint system (CRS) in the left rear vehicle seat in 4 seating orientations: 0° (forward-facing position), 30°, 60°, and 90° (living room position). Two scenarios were evaluated for all seating orientations according to the left front seat backrest position: reclined position nominal upright and rest position (55°). All seat configurations were subjected to the mobile progressive deformable barrier frontal impact (European New Car Assessment Programme [Euro NCAP] frontal impact testing protocol). A total of 8 scenarios were simulated in LS-DYNA. Results Based on the Euro NCAP injury risk rate, 90° seating orientation (living room position) was the safest among all selected scenarios independent of the left front seat backrest position. The worst case was found in 60° seat rotation. The highest values for Head Injury Criterion (HIC) and head acceleration (Acc 3 ms) were noted for this case. Higher Brain Injury Criterion (BrIC) values were observed at higher seat rotation angles. Hence, a 90° seating orientation showed the highest BrIC value. Attending to the skull stress, greater head injuries were caused principally by contact with the vehicle interior (seat headrest). Maximum stress values were reached at 30° and 60° seating orientations with the front seat in rest position. In 90° seating orientation, high stress values were also identified. Conclusions These results show that attending to these new seating orientations, current child safety standards are not sufficient to ensure children the highest level of protection. Other additional criteria such as BrIC or skull stress that offer a way to capture brain injuries should be used.