Simultaneous methanogenesis and denitrification of aniline wastewater by using anaerobic–aerobic biofilm system with recirculation

Abstract

Wastewater containing highly concentrated nitrogenous and aromatic compounds, such as aniline, is difficult to degrade and very toxic to microorganisms, especially to nitrifier. In order to remove both carbon and nitrogen from aniline wastewater, recently two biofilm reactors equipped with anaerobic–aerobic cycle and internal recirculation have demonstrated some potential in treating the wastewater. In such system, ammonification, methanogenesis and denitrification reactions occurred simultaneously in one anaerobic reactor, followed by COD removal and nitrification in the aerobic reactor. The effect of recirculation ratio on COD and nitrogen removal using such reactor arrangement was therefore investigated in the present work. The results showed that recirculation had little impact on the overall COD removal or denitrification activity in the anaerobic reactor at any tested ratio, 96–98% of overall COD removal efficiency was achieved with a final effluent COD value below 200 mg/L. But nitrification and TN removal were strongly affected by recirculation. The nitrification rate reached a maximum of 0.48 kg N/(m 3 d) at recirculation ratio of 1 and complete nitrification was achieved at the recirculation ratios over 2. TN removal efficiency increased continuously and a sharp reduction of sludge production in the system was observed with increasing recirculation.