Roles of lipid oxidation and pH on properties and yellow discolouration during storage of film from red tilapia ( Oreochromis niloticus) muscle protein

Abstract

Protein-based films prepared from red tilapia ( Oreochromis niloticus) washed and unwashed mince solubilised at pH 3 and 11 were prepared and characterised. Tensile strength (TS) of films from washed mince was greater than that of films prepared from unwashed mince for both pH used ( P < 0.05). TS of films prepared at pH 3 was higher than that of films prepared at pH 11 for both of washed and unwashed mince ( P < 0.05). Film from washed mince with pH 3 showed the highest TS, while that from unwashed mince with pH 11 had the lowest TS with the highest elongation at break (EAB) ( P < 0.05). Films from washed mince had the lower value of thiobarbituric acid reactive substances (TBARS) than did those from unwashed counterpart, regardless of pH used. Nevertheless, TBARS was much higher in films prepared at acidic pH, compared with those prepared at alkaline pH. During storage of 20 days at room temperature, films became yellowish as evidenced by the increases in b ∗ and Δ E ∗-values. Films prepared at pH 11 showed the higher b ∗ and Δ E ∗-values than did those prepared at pH 3, especially for those from unwashed mince. However, films prepared from washed mince at pH 3 showed higher b ∗ and Δ E ∗-values than did those prepared at pH 11 ( P < 0.05). Films generally had the increase in TS but the decreases in water vapour permeability (WVP), film solubility and protein solubility after 20 days of storage ( P < 0.05). Therefore, lipid oxidation more likely played a role in yellow discolouration of fish muscle protein film, mainly by providing the carbonyl groups involved in Maillard reaction, while pH regulated the rate of reaction.