Reproductive performance and quality of offsprings of parent stock of layer hens after rearing in open and closed aviary system

Abstract

In this study, we analyzed the parent stock of ISA Brown hens reared in closed and open aviary (CA and OA, respectively) sections with regard to the productive performance of hens, hatchability, and quality of chicks. The flocks were reared (1,570 cocks and 17,515 hens) for 16 wk in a three-level aviary system. On the 7th wk of rearing, half of the birds (OA group of birds) were allowed to leave the section and use half of the area of the poultry house and to use all levels. The remaining half of the birds were kept in the CA section for the entire duration of rearing. After the duration of rearing, the birds were moved to 2 neighboring production poultry houses (OA = 680 cocks and 8,126 hens; CA = 685 cocks and 8,133 hens). Reproduction was performed in a litter system in accordance with the norms for parent stock of laying hens. During the production cycle (53 wk), laying performance, feed conversion ratio, water consumption, and mortality were analyzed. On 27th, 37th, and 49th wk of production, the following analysis was performed: rate of fertilization (%), rate of hatching (%), and quality of chick. In accordance with the results, birds in OA flock required less amount of feed (P < 0.001) and water (P = 0.020) to produce a laid egg, a hatching egg (respectively: P < 0.001; P = 0.009), and a chick (both P < 0.001) in comparison with the birds in CA flock. In addition, a lower number of litter eggs were found in the OA flock (P < 0.001). Mean laying production, production of hatching eggs, and number of waste eggs did not depend on the flock rearing system (P > 0.05); however, a combined analysis of all these parameters using multivariate analysis of variance demonstrated a better (P < 0.001) result for OA flock than that of CA flock. Rate of fertilization, rate of hatching, and quality of chicks did not depend on the flock rearing system (P > 0.05). In summary, it is possible to rear parent ISA Brown hens in open sections of aviary system without the fear of subsequent deterioration of indicators of future egg production.