Removal of recalcitrant organic matter of landfill leachate by adsorption onto biochar from sewage sludge: A quali-quantitative analysis

Abstract

Sewage sludge is a byproduct of sewage treatment, whereas landfill leachate is a complex wastewater generated by the decomposition of solid waste. These byproducts require adequate management, and one option for the sludge is the thermal treatment by pyrolysis to produce biochar. The resulting biosolid can be used as an adsorbent to treat landfill leachate. The main objective of this research was to remove recalcitrant organic matter from landfill leachate by adsorption onto biochar produced from sewage sludge. Aerobic and anaerobic sludges were pyrolyzed at 450, 650 and 850 °C, under residence times of 60, 90 and 120 min. Temperature had a positive and more significant impact on the characteristics of the biochars produced, and consequently on the adsorption of recalcitrant organic matter. However, the impact of residence time was less intense and, in some cases negative. Biochars produced from both aerobic and anaerobic sludge pyrolyzed at 850 °C for 120 and 60 min, respectively, showed higher specific surface areas (114.4 m2g-1 and 104.2 m2g-1, respectively) compared with those pyrolyzed at 450 °C and 650 °C. The biochar from anaerobic sludge produced at 850 °C and 60 min showed the best performance regarding the adsorption process, with chemical oxygen demand (COD), dissolved organic carbon (DOC), and color removals from the leachate of 32%, 36%, and 41%, respectively. The results of adsorption capacity for this biochar from anaerobic sludge were 26.1 mg g−1 for COD and 7.9 mg g−1 for DOC. The adsorption of recalcitrant organic matter from leachate was evidenced by the decrease in the UV–Vis absorbances and fluorescence intensities. It indicates that recalcitrant and humic substances were removed mainly by biochars pyrolyzed at 850 °C. Thus, the results allow to stress that the pyrolysis of sewage sludge to produce biochar is a promising alternative to sludge treatment, and the biochar may be applied as a pre-treatment of landfill leachate since it successfully removed the recalcitrant organic matter.