Abstract
Low dielectric constant (low-k) films have been prepared by remote plasma-enhanced chemical vapor deposition from vinyltrimethylsilane which has one vinyl group along with three methyl groups attached to silicon. The films have been characterized as-deposited and after annealing at 450°C. As-deposited films showed a dual-phase nanostructure, and the formation of nanopores was observed from annealing as confirmed by transmission electron microscope. The structure and composition of the films were investigated by Fourier transform infrared spectroscopy and X-ray photoelectron spectroscopy. The growth rate decreased with increasing substrate temperature in the range of room temperature to 100°C, and above 70°C a substantial film growth was not observed. The relative carbon content and dielectric constant were observed to decrease after annealing. It was observed that a thermally unstable phase is removed after annealing and the desorption of the labile phase makes additional nanopores in the film. After annealing, the increase of porosity was 15-20% against the thermal oxide, calculating from the Lorentz-Lorentz equation. SiCOH films showed a low dielectric constant of 2.1 and a leakage current density of at 1 MV/cm at an optimum condition. © 2002 The Electrochemical Society. All rights reserved.
Talk to us
Join us for a 30 min session where you can share your feedback and ask us any queries you have
Schedule a callDisclaimer: All third-party content on this website/platform is and will remain the property of their respective owners and is provided on "as is" basis without any warranties, express or implied. Use of third-party content does not indicate any affiliation, sponsorship with or endorsement by them. Any references to third-party content is to identify the corresponding services and shall be considered fair use under The CopyrightLaw.
