Refractive Laser Beam Measuring Diffusion Coefficient of Concentrated Battery Electrolytes

Abstract

Listen

Translate article

A thorough understanding of electrolyte transport properties is crucial in the development of alternative battery technology. As a key parameter, the diffusion coefficient offers important insights into the behavior of electrolytes, especially for fast charge of high-energy batteries. Existing methods of measurement are often limited by redox species or offer questionable accuracy due to side reactions and/or disruption of the diffusion profile. A highly sensitive optical method was developed using a refractive laser beam through triangular diffusion column to measure the diffusion coefficient of concentrated battery electrolytes. The method based on Snell’s law can be applied to all liquid phase electrolytes since the refractive index is concentration dependent for all liquid electrolytes. This universal method relies on the deflection of a refractive laser beam passing through an electrolyte of a minor concentration gradient in a triangular diffusion column (Figure 1). A polarized HeNe laser was arranged to pass the beam through a right-angled triangular quartz precision cell, slightly rotated to the normal. The exact position of the refracted beam was located by a silicon photodiode-based position detector. Deflection calibration curves made simple conversion of beam position to concentration, and during the diffusion of two layered solutions, data points were collected every minute to produce a concentration profile descriptive of the 48-hour diffusion. Diffusion coefficients were calculated using a model based on OSM theory, accounting for multi-component concentrated systems in a restricted diffusion column.1 The measured diffusion coefficients are between 4.12x10-10 m2/s for 0.15 mol/kg ZnSO4 and 0.681x10-10 m2/s for 2.5 mol/kg ZnSO4 at 22.4 °C. The profile of concentration-dependent diffusion coefficients follows a non-linear inverse relationship described by the function D=4.943(1+m)-1.564 (Figure 2).Several other physicochemical properties of the same electrolytes were studied to correlate to the concentration-dependent diffusion coefficients, including refractive index, viscosity, conductivity, and microstructure analysis based on vibrational spectroscopy (Infrared and Raman). High concentration electrolytes with more ion pairs show increased viscosity which ultimately leads to smaller diffusion coefficients. A QCM-I instrument standard flow cell were used to determine the viscosity of ZnSO4 electrolyte and the concentration-dependent viscosity was fitted to the function η=1.06-0.476m+2.13m2-1.01m3+0.204m4. Interionic interactions also led to reduced conductivity at concentrations beyond 1.5mol/kg, despite the increased charge density of concentrated solutions. FT-IR spectrums allowed analyzation of increased charge density, which increased intensity of the O-H stretching peak in concentrated electrolytes, despite the decrease in the ratio of water. Competition between charge density and viscosity continues to challenge the efficiency of concentrated electrolytes.Lastly, we demonstrate the prototype in situ triangular cell to characterize the electrolyte in working batteries. The cell responds to short, low-voltage pulses with beam deflection and relaxation, and offers an opportunity as a novel in situ spectroscopic tool to characterize the battery electrolyte. Acknowledgments This work is supported by a grant from NSF (CBET-2243098).