Abstract
As an alternative to heat and gas exposure sterilization, ionizing radiation is gaining interest as sterilization process for medicinal products. Detection and dosimetry of pharmaceuticals radiosterilization is a growing concern to numerous government regulatory agencies worldwide. In this context, it is necessary to find methods distinguishing between irradiated and non-irradiated pharmaceuticals. In the absence of suitable detection methods, our attention was focused on electron spin resonance (ESR) spectrometry. A third generation cephalosporin, cefotaxime, was chosen as model; this antibiotic is a potential candidate for radiation treatment due to its thermosensitivity. While the ESR spectra of a nonirradiated sample presents no signal, a signal, dependent of the irradiation dose, is found in irradiated samples. The number of free radicals was estimated by comparing the second integral from radiosterilized samples and a diphenylpicrylhydrazyl reference. Estimation of the number of free radicals gives 1.9 × 1020 radicals mol-1 at 20 kGy. From this result, the G-value (number of radicals (100 eV)-1) could be estimated to 0.3. Aside from qualitative detection, ESR spectrometry can be used for dose estimation. When quadratic, exponential or bi-exponential functions are applied to the variation of peak to peak amplitude vs. dose, these functions correlate well with the data. However, it is important to notice that linear function correlates well with the data for doses lower than 20 kGy. Since the radiation dose selected must be always based upon the bioburden of the products and the degree of sterility required (EN 552 and ISO 11137) 25 kGy could no longer be accepted as a “routine dose” for sterilizing a pharmaceutical. Doses from 6 kGy (ISO 11137) could be investigated and linear regression would appear to be the least expensive route to follow. The free radicals concentration appeared to not decrease during the 57 days of storage; the number generated during the irradiation allows the detection of radiosterilized cefotaxime up to two years after irradiation.
Talk to us
Join us for a 30 min session where you can share your feedback and ask us any queries you have
Disclaimer: All third-party content on this website/platform is and will remain the property of their respective owners and is provided on "as is" basis without any warranties, express or implied. Use of third-party content does not indicate any affiliation, sponsorship with or endorsement by them. Any references to third-party content is to identify the corresponding services and shall be considered fair use under The CopyrightLaw.