Production of antioxidant soy protein hydrolysates by sequential ultrafiltration and nanofiltration

Abstract

Soy protein hydrolysates, produced by enzymatic hydrolysis of soy protein isolate (SPI) with pepsin and pancreatin, were subjected to sequential ultrafiltration (UF) and nanofiltration (NF). Heat treatment of SPI prior to enzymatic hydrolysis was investigated for its effect on ORAC and FCR antioxidant capacity of the fractions. The ORAC antioxidant capacity was significantly higher than the FCR antioxidant capacity for any given fraction. The UF permeate fractions (MW smaller than 10kDa), containing approximately 50% of the feed total solids, displayed higher ORAC antioxidant capacity compared to the corresponding feed and retentate fractions for soy protein hydrolysate produced from SPI with heating (H-SPH) and without heating (SPH). In contrast, the FCR antioxidant capacity of the UF fractions was affected by SPI heating. The UF permeate fraction had higher FCR antioxidant capacity when compared to the UF retentate for SPH produced from SPI with no heating. The NF permeate fractions produced at pH 8 with a 2.5kDa MWCO thin film composite membrane displayed the highest ORAC antioxidant capacity, 5562μmolTEg−1 TS (SPH) and 5187μmolTEg−1 TS (H-SPH). Due to the significant improvement of the ORAC antioxidant capacity with a loose NF membrane at pH 8, the potential for NF as a viable industrial fractionation process for soy protein hydrolysates with antioxidant capacity was demonstrated.