Abstract
Indonesia is one of the largest rubber producers worldwide. However, rubber seeds still garner less attention due to their low economic value. In fact, the rubber seeds contain 40–50% (w/w) of rubber seed oil (RSO), which is a potential candidate to be used as a feedstock in biodiesel production. In this regard, this study aims to model and simulate the production process of biodiesel from RSO via transesterification reaction, employing methanol and heterogeneous catalyst. The simulation was performed using ASPEN Hysys v11. Acid-based catalyzed esterification was implemented to eliminate soap formation, which may significantly lower biodiesel yield. The results showed that an RSO inlet rate of 1100 L/h with a methanol to oil molar ratio of 1:6 could generate around 1146 L/h biodiesel. Methanol recovery was conducted, an approximately 95% of excess methanol could be regenerated. Simulation results indicated that the properties of the biodiesel produced are compatible with modern diesel engines. Economic analysis also shows that this technology is promising, with excellent investment criteria.
Talk to us
Join us for a 30 min session where you can share your feedback and ask us any queries you have
Disclaimer: All third-party content on this website/platform is and will remain the property of their respective owners and is provided on "as is" basis without any warranties, express or implied. Use of third-party content does not indicate any affiliation, sponsorship with or endorsement by them. Any references to third-party content is to identify the corresponding services and shall be considered fair use under The CopyrightLaw.