Preparation, characterization and optimization of sildenafil citrate loaded PLGA nanoparticles by statistical factorial design.

Elham Ghasemian,Abdolhossein Rouholamini Najafabadi,Majid Darabi,Alireza Vatanara,Kambiz Gilani,Mohammad Reza Rouini

doi:10.1186/2008-2231-21-68

Elham Ghasemian, Abdolhossein Rouholamini Najafabadi + Show 4 more

Open Access

https://doi.org/10.1186/2008-2231-21-68

Copy DOI

Abstract

Background and the aim of the studyThe objective of the present study was to formulate and optimize nanoparticles (NPs) of sildenafil-loaded poly (lactic-co-glycolic acid) (PLGA) by double emulsion solvent evaporation (DESE) method. The relationship between design factors and experimental data was evaluated using response surface methodology.MethodA Box-Behnken design was made considering the mass ratio of drug to polymer (D/P), the volumetric proportion of the water to oil phase (W/O) and the concentration of polyvinyl alcohol (PVA) as the independent agents. PLGA-NPs were successfully prepared and the size (nm), entrapment efficiency (EE), drug loading (DL) and cumulative release of drug from NPs post 1 and 8 hrs were assessed as the responses.ResultsThe NPs were prepared in a spherical shape and the sizes range of 240 to 316 nm. The polydispersity index of size was lower than 0.5 and the EE (%) and DL (%) varied between 14-62% and 2-6%, respectively. The optimized formulation with a desirability factor of 0.9 was selected and characterized. This formulation demonstrated the particle size of 270 nm, EE of 55%, DL of 3.9% and cumulative drug release of 79% after 12 hrs. In vitro release studies showed a burst release at the initial stage followed by a sustained release of sildenafil from NPs up to 12 hrs. The release kinetic of the optimized formulation was fitted to Higuchi model.ConclusionsSildenafil citrate NPs with small particle size, lipophilic feature, high entrapment efficiency and good loading capacity is produced by this method. Characterization of optimum formulation, provided by an evaluation of experimental data, showed no significant difference between calculated and measured data.

Highlights

Obesity has reached epidemic proportions and is still escalating at an alarming rate worldwide
Obesity is associated with chronic activation of low-grade inflammation [3], which is implicated in the pathogenesis of obesity-associated diseases including insulin resistance, type-2 diabetes (T2D) [4, 5] and cardiovascular disease [6, 7]
A numerous of studies has been shown that shortchain fatty acids (SCFAs) inhibit inflammation with focus on butyrate and to a lesser extent on acetate and Propionic Acid (PA), [16]

Summary

Introduction

Obesity has reached epidemic proportions and is still escalating at an alarming rate worldwide. In Palestine the prevalence of obesity has been shown to be approximately 4. The etiology of obesity and low-grade inflammation is complex and involves intrinsic and extrinsic factors. The colonization of germ-free mice with microbiota derived from obese mice results in significantly greater adiposity than colonization with microbiota from lean mice [12]. Prebiotic diets such as fructans [13] are associated with general better health, including the decrease in body weight, fat mass and the severity of T2D [14,15,16]. The factors that influence the composition and metabolism of intestinal

Objectives

Methods

Results

Conclusion