Premilking teat disinfection: Is it worthwhile in pasture-grazed dairy herds?

Abstract

A controlled trial was conducted in 5 pasture-grazed commercial dairy herds in Australia in 2012 to determine whether premilking teat disinfection and drying of teats reduces clinical mastitis incidence during early lactation by at least 50%. A 50% reduction was estimated to be the minimum required to justify additional costs of labor, disinfectants, and other resources if premilking teat disinfection was implemented in a 500-cow herd averaging 8 clinical cases per 100 cow-months. A secondary aim was to determine whether this premilking teat disinfection routine reduces incidence of new udder infections. Treatment was applied in each herd for approximately 60 d (range of 59.5 to 61 d), commencing in each herd soon after the start of the herd's main or only calving period. Within each herd, cows were allocated to either the treatment (premilking disinfection) or the control (no premilking disinfection) group based on their herd identity number. During the trial period, any cow having a new case of clinical mastitis or an individual cow cell count greater than 250,000 cells/mL of milk (when preceded by individual cow cell counts of 250,000 cells/mL of milk or below) was deemed to have had a new infection. Overall, neither clinical mastitis incidence nor new infection rate differed significantly between treatment and control groups. Over the whole study period, 98 of the 1,029 cows in the premilking disinfection group and 97 of the 1,025 cows in the control group had clinical mastitis. Total cow-days at risk of clinical mastitis were similar in each group. However, clinical incidence rates were markedly lower in treatment cows in one herd (herd 3; incidence rate ratio=0.34) and there was some evidence that new infection incidence rates were lower in treated cows in this herd (incidence rate ratio=0.42). Rainfall during the study period was below long-term district average in all 5 study herds. Cows’ teats were less dirty than in previous, wetter years for the 4 herds where no significant clinical mastitis response was detected but some teat soiling was observed in herd 3 during the study period. Routine application of premilking teat disinfection in pasture-grazed herds is unlikely to produce a worthwhile (economic) reduction in the number of clinical mastitis cases when teats are relatively clean and dry and the clinical mastitis incidence is low. However, premilking disinfection might be worthwhile during periods when teats are heavily soiled and the incidence of clinical mastitis due to environmental pathogens is high.