Preliminary bronchodilator dose effect on aerosol-delivery through different nebulizers in noninvasively ventilated COPD patients

Abstract

Objectives: This study aimed to evaluate the effect of a preliminary bronchodilator dose on the aerosol-d elivery by different nebulizers in noninvasively ventilated chronic obstructive pulmonary disease (COPD) patients. Method: COPD patients were randomized to receive study doses of 800 µg beclomethasone dipropionate (BPD) nebulized by either a vibrating mesh nebulizer (VMN) or a jet nebulizer (JN) connected to MinimHal spacer device. On a different day, the nebulized dose of beclomethasone was given to each patient by the same aerosol generator with and without preceded two puffs (100 µg each) of salbutamol delivered by a pressurized-metered dose inhaler. Urinary BPD and its metabolites in 30 min post-inhalation samples and pooled up to 24 h post-inhalation were measured. On day 2, ex-vivo studies were performed with BPD collected on filters before reaching patients which were eluted from filters and analyzed to estimate the total emitted dose. Results: The highest urinary excretion amounts of BPD and its metabolites 30 min and 24 h post-inhalation were identified with pMDI + VMN compared with other regimens(p < 0.001). The amounts of BPD and its metabolites excreted 30 min post inhalation had approximately doubled with pMDI + JN compared with JN delivery (p < 0.05). No significant effect was found in the ex-vivo study results except between VMN and JN with a significant superiority of the VMN (p < 0.001). Conclusion: Using a preliminary bronchodilator dose before drug nebulization significantly increased the effective lung dose of the nebulized drug with both VMNs and JNs. However, adding a preliminary bronchodilator dose increased the 24 hr cumulative urinary amount of the drug representing higher systemic delivery of the drug, which in turn could result in higher systemic side effects.