Performance of Foriegn and Local Agents for Enhanced Oil Recovery of Nigerian Crude

Abstract

Abstract Nigeria is gradually advancing into the secondary stage of oil recovery, necessitating preparation for tertiary oil recovery especially enhanced oil recovery (EOR). Considering the high cost of EOR agents, it is imperative to investigate the performance of available local EOR agents against foreign agents when these agents (such as surfactants and polymers) are used in combination. Oil displacement experiments were thus conducted using foreign and local surfactant-polymer (SP) and alkaline-polymer (AP) agents on Nigerian crude and their results were compared. The experiments entailed using different percentage ratios of surfactants to polymers and alkaline to polymer. Four kinds of Alkaline were also used to displace residual oil from sand to find out what type of alkaline displaces oil better. The displacement efficiencies obtained from experimental results showed that the foreign EOR agents performed better than the local EOR agents. For the SP agents, the foreign SP displaced above 90% of both light and medium crude at about 45/55 percentage and 0/100 percentage respectively. The local SP displaced a maximum of about 35% of the light crude and 75% of medium crude at an SP ratio of about 20/80 for both cases. The use of Alkaline-Polymer results showed that the foreign agents performed better than the local agents. The maximum displacement efficiency of the foreign AP was 78.13% at a ratio of 40/60 while the maximum displacement efficiency of the local AP was 64% at a ratio of 60/40. The displacement of residual oil experiments performed using four kinds of alkaline showed that potassium hydroxide (KOH) enhances recovery better than NaOH, Na2CO3 and Palm bunch ash (a local source of alkaline). It was also observed that oil displacement efficiency increased as pH value of the alkaline increased.