Abstract

Performance evaluation of two reverse osmosis (RO) desalination plants (DSP) at villages: Melasirupodhu (30 m3 day(-1)) and Sikkal (50 m3 day(-1)) in Ramanathpuram district, Tamil Nadu (India) were studied so as to bring out the state-of-art of their operation and maintenance (O&M). Detailed information on plant design and engineering, water quality, plant personnel, and cost of O&M was collected for a period of three years after commissioning of the two plants. Feed water was brackish, the TDS varied in the range of 6500-8500 mg L(-1) at Melasirupodhu and 5300-7100 mg L(-1) at Sikkal villages. The product water quality was observed to be gradually deteriorating as the salt rejection by the membranes decreased with time. The salt rejection was 97-99% at the time of commissioning of the plants, and came down to 89-90% at the end of 3 years of operation. Product water TDS soon after installation of the plants was excellent and within desirable limits of BIS. After three years of operation, few parameters exceeded the desirable limits, however, they were found to be within permissible limits of BIS. The analyses of the data showed that both plants were operated only at 30-36% of the design capacity. Plant shut-down due to inadequate and erratic power supply, and plant break-down and inherent delay in repairs due to lack of adequate infrastructure were found to be the major causes for the low utilization of the plants. Consequently the recurring cost of product water production enhanced to Rs. 25.0/m3 at Melasirupodhu and Rs. 17.5 m(-3) at Sikkal, as against the estimated cost of Rs. 15.0/m3 and Rs. 11.0/m3, respectively, as per the design. Over the years, the energy consumption for the product water output increased reflecting higher operational pressures needed with the aging of the membranes.

Full Text
Published version (Free)

Talk to us

Join us for a 30 min session where you can share your feedback and ask us any queries you have

Schedule a call