One-pot catalytic conversion of sugars to methyl lactate over acid-base bifunctional Sn/MgO catalysts

Abstract

Alkyl lactates represent such green added-value chemicals that commonly used as biodegradable green solvents, detergents, pharmaceutical intermediates et al. Catalytic conversion of carbohydrates to methyl lactate (MLA) is a representative way for high-value utilization of biomass and the key lies in the development of highly efficient catalysts. In methanol, strong acid or alkaline catalysts are usually used under high temperature and high pressure, suffering from problems such as low selectivity, high cost or contamination of environment. This study aims to develop an acid-base bifunctional heterogeneous catalyst for the one-pot conversion of sugars to MLA under mild conditions. Sn/Mg composite oxides was synthesized by a coprecipitation method and further modified by poly (vinyl imidazole) ([PVIM]) to tune the hydrophilicity. Effect of polymer and Sn amount, calcination temperature, reaction temperature, catalyst dosage, and substrate concentration were investigated. The acid-base properties were characterized by NH3-TPD, pyridine-FTIR and CO2-TPD analysis. It was found that the presence of medium acid sites and medium base sites played an important role to the cascade reactions of carbohydrates to MLA. An optimum MLA yield of 55.4% was achieved over 10[PVIM]-5Sn/MgO (0.05 g) with complete conversion of glucose (28 mM) at 140 ℃, 2 MPa N2 for 10 h. The reaction conditions are mild and no strong acid or strong base catalyst is required. Furthermore, a possible reaction mechanism was proposed that the introduction of [PVIM] effectively regulated the local microenvironment of active sites and the acid base synergism greatly promoted the retro-aldol condensation, dehydration and hydrogen transfer reactions during the conversion of glucose to MLA.