OBSERVATIONS ON FLOORING AND STALL SURFACES FOR DAIRY CATTLE HOUSED IN A FREE-STALL BARN

Abstract

Lameness, an insidious economic and welfare problem in dairy cattle, is directly influenced by thedesign of modern housing. In particular, concrete flooring and uncomfortable stalls are associatedwith increased incidence of lameness in free-stall barns. As group size increases in large herds, theeffects of prolonged standing in the pre-milking holding area on claw health is a growing concern.In two experiments, the effects of these housing features on hind claw and leg health and on netgrowth rate of hoof horn were studied. In the first study, 120 lactating Holstein cows were assigned to one of 6 free-stall pens, each with adifferent configuration of 3 stall surfaces (deep sand, rubber-filled mattresses or concrete) and 2flooring surfaces (grooved concrete or rubber mats), for 105 days. Hind claws and hocks werescored for lesions before and after the treatment period and the increase in score was recorded.Locomotion score was recorded monthly to assess the incidence of clinical lameness, and rates ofclaw growth and wear were measured at the dorsal wall. Claw lesions increased significantly forall groups except those with rubber alleys and either concrete or sand stalls. An all-groupcomparison of the increase in claw score and incidence of clinical lameness did not yieldsignificant differences. Sand stalls prevented hock lesions and were significantly better for hocklesions than the pen with concrete stalls and alleys. Net growth rates of claws were highest incows housed in pens with concrete alleys and mattress stalls and lowest with rubber alleys andsand stalls, indicating different levels of tendency toward hoof overgrowth: the combinations thatproduced higher net growth would likely require more frequent corrective foot trimming. In the second study, 80 Holstein heifers were assigned to one of four treatment pens in a 2 x 2factorial design and were subjected to simulated pre-milking holding pen conditions three timesdaily for 112 days. Heifers were held by headlocks (installed along one side of a free-stall pen) for45 or 90 minutes, and stood on a concrete floor that had either a 5% slope or a flat surface.Increase in hind-claw lesion score and rates of growth and wear for hind lateral claws weremeasured as previously described. Increase in claw lesion score was significantly lower foranimals on the sloped surface. A longer time standing was not associated with higher scoreincreases.Animals standing for 90 minutes had significantly higher rates of horn growth; however,rates of wear or net growth did not differ. Compared with a flat surface, a slope maintains a drierenvironment for the feet, an important property that appeared to prevent the formation of hindclawlesions, even as animals stood on the surface for up to 4.5 hours per day.