Numerical Evaluation of Commingled Production Potential of Marine Multilayered Gas Hydrate Reservoirs Using Fractured Horizontal Wells and Thermal Fluid Injection

Abstract

Multilayered reservoirs with coexisting free gas and hydrates are primary targets for commercialization, nevertheless, the extremely low permeability greatly limits their extraction efficiency. Herein, multilayer commingled production using horizontal wells stimulated by hydraulic fracturing and thermal fluid injection was proposed to enhance productivity, and the effects of key factors on co-production performance were numerically examined, with the reservoir located in the Shenhu Area as the geological background. The results indicated that due to severe interlayer contradictions, the stimulation capabilities of using fracturing or thermal fluid injection alone were limited, in particular, the extraction of hydrates severely lagged behind. However, their combination exhibited tantalizing productivity due to strengthened inter-well interaction. Reducing the fracture spacing was more effective than increasing fracture conductivity in shortening the production cycle, and intensive fractures with adequate flow capacity were suggested for gas enhancement and water control. When the fracture spacing was reduced from 30 to 5 m and the fracture conductivity increased from 10 to 100 D·cm, the horizontal section length for commercial production (average daily gas production of 50,000 m3 and recovery ratio of 0.7) was reduced from 1758 to 146 m, which is lower than the on-site horizontal section length of 250–300 m. Therefore, the proposed development mode is promising for the commingled production of gas and hydrates.